Adjusting The Transmission - Toro TurfMaster 22205TE Operator's Manual

6. Loosen the bracket and rotate the bracket forward
(Figure 51).
Note: The bracket prevents the transmission from
tipping to the point where the transmission belt comes
off.
1. Transmission tension
spring
2. Bracket
3. Transmission
7. Remove the transmission tension spring.
8. Remove the transmission belt from the transmission
pulley.
9. Remove the transmission belt.
10. To install a new transmission belt, reverse the steps
above.

Adjusting the Transmission

If the machine starts to lose traction, check and adjust the
transmission.
1. Shut off the engine and wait for all moving parts to
stop.
2. Disconnect the wire from the spark plug.
3. Loosen the bolt and nut holding the bracket into place.
4. Adjust the bracket so that it is in contact with the
transmission.
Note: The bracket prevents the transmission from
tipping to the point where the transmission belt comes
off.
5. Tighten the bolt and nut to secure the bracket into
place.
Adjusting the Self-Propel
Cable
If the machine does not self-propel or tends to creep forward
when you release the control bar, adjust the drive cable.
Figure 51
4. BBC belt
5. Transmission belt
SUPERCEDED
1. Stop the machine and wait for all moving parts to stop.
2. Loosen the cable-support nut
1. Cable-support nut
g196531
3. Slide the cable-support nut toward the machine to
increase the self-propel action; slide the cable-support
nut away from the machine to decrease the self-propel
action.
4. Tighten the cable-support nut.
5. Check the operation for the desired drive control, and
repeat the steps above, if necessary.
Note: If the machine creeps forward without the
control bar engaged or if the wheels spin when you
lift the rear wheels off the ground, the cable is too
tight; loosen the cable-support nut, pull the cable jacket
upward (away from the machine) slightly, and tighten
the cable-support nut.
Note: You may also adjust the maximum ground
speed (when the control bar is fully engaged) as desired.
27
(Figure 52).
1
G019876
Figure 52
g019876