Installation Standard Work Checklist - Heatilator HEIR36H-IFT Installation Manual

Installation Standard Work Checklist

This standard work checklist is to be used by the installer in conjunction with, not instead of, the instructions contained in
this installation manual.
Customer:
Lot/Address:
Model (circle one): HEIR36-IFT
HEIR42-IFT
WARNING! Risk of Fire or Explosion! Failure to install appliance according to these instructions could lead to
a  re or explosion.
Appliance Install Information
Veri ed clearances to combustibles requirements are maintained. (Pg. 12-15)
Veri ed that the chase is insulated and sealed. (Pg. 16)
Veri ed mantel and wall clearance requirements are maintained. (Pg. 48-49)
Veri ed hearth extension requirements are maintained. (Pg. 17)
Veri ed appliance is leveled and secured. (Pg. 34)
Veri ed required factory-supplied non-combustible board installed. (Pg. 35)
Venting/Chimney Section 7 (Pg. 36-39)
Veri ed venting con guration complies to vent diagrams.
Veri ed venting installed, locked and sealed/secured in place.
Veri ed venting meets clearance to combustible requirements.
Veri ed wall/ceiling  restops are installed (if applicable).
Veri ed attic insulation shield is installed (if applicable).
Veri ed Exterior wall/Roof  ashing is installed and sealed.
Veri ed termination cap is installed and sealed.
Electrical Section 8 (Pg. 40-42)
Veri ed unswitched power (110-120 VAC) provided to the appliance.
Veri ed wall switch wires are properly installed (if applicable).
Gas Section 9 (Pg. 43-44)
Veri ed appliance is using proper fuel type.
If converted, veri ed proper fuel conversion kit was used.
Veri ed that gas components ( ttings, pressure taps, etc) are leak free and  replace is
operating under correct pressures.
Finishing Section 10 (Pg. 45-50)
Veri ed that  nish material does not interfere with install/operation of decorative front.
Veri ed combustible materials are not installed in non-combustible areas.
Veri ed all clearances meet installation manual requirements.
Veri ed mantels/wall projections comply with installation manual requirements.
Appliance Setup Section 11 (Pg. 51-59)
Veri ed all packaging and protective materials are removed (inside & outside of appliance).
Veri ed Lava Rock, Mystic Embers, Glowing Embers, and logs installed correctly.
Veri ed  xed glass assembly installed and secured.
Veri ed that a required decorative door option is installed properly.
Veri ed remote control has been programmed and is fully functional.
Veri ed proper air shutter setting for installation type and vent con guration.
Manual bag and all of its contents are removed from inside/under
the appliance and given to party responsible for use and operation.
Hearth & Home Technologies recommends the following:
• Photographing the installation and copying this checklist for your  le.
• That this checklist remain visible at all times on the appliance until the installation is complete.
Comments: Further description of the issues, who is responsible (Installer/ Builder/ Other Trades, etc) and corrective
action needed ____________________________________________________________________________________
Comments Communicated to party responsible ____________________ by ______________________on ___________
 = Contains updated information.
Heatilator • HEIR36-IFT, HEIR42-IFT, HEIR50-IFT Installation Manual • 2458-980 Rev. B • 8/17
ATTENTION INSTALLER:
Follow this Standard Work Checklist
HEIR50-IFT
(Builder / Gen. Contractor/) (Installer)
Date Installed:
Location of Fireplace:
Installer:
Dealer/Distributor Phone #
Serial #:
YES IF NO, WHY?
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
___________________
(Date)
2458-982 12/16
3