Table of Contents
Advertisement
Installation Standard Work Checklist
This standard work checklist is to be used by the installer in conjunction with, not instead of, the instructions contained in this
installation manual.
Customer:
Lot/Address:
Model (circle one):
WARNING! Risk of Fire or Explosion!
to a fire or explosion. Install ONLY components and accessories approved by Hearth & Home Technologies.
Unapproved components and accessories could cause fireplace to overheat.
Appliance Install
Verified that the chase is insulated and sealed. (Pg. 14)
Verified clearances to combustibles. (Pg. 12-13)
Fireplace is leveled and secured. (Pg. 36)
Venting/Chimney Section 7 (Pg 37-43)
Venting configuration complies to vent diagrams.
Venting installed, locked and secured in place with proper clearance.
Firestops installed.
Attic insulation shield installed.
Exterior wall/Roof flashing installed and sealed.
Terminations installed and sealed.
Electrical Section 8 (Pg 44-46)
Unswitched power (110-120 VAC) provided to the appliance.
Switch wires properly installed.
Gas Section 9 (Pg 47-48)
Proper appliance for fuel type.
Was a conversion performed?
Leak check performed and inlet pressure verified.
Verified proper air shutter setting for installation type.
Finishing Section 10 (Pg 49-50)
Combustible materials not installed in non-combustible areas.
Verified all clearances meet installation manual requirements.
Mantels and wall projections comply with installation manual requirements.
Appliance Setup Section 11 (Pg 51-54)
All packaging and protective materials removed (inside & outside of appliance).
Refractories, logs, mineral wool, lava rock and vermiculite installed correctly.
Glass assembly installed and secured.
Accessories installed properly.
Decorative barrier front properly installed.
Manual bag and all of its contents are removed from inside/under
the appliance and given to party responsible for use and operation.
Started appliance and verified no gas leaks exist.
Hearth & Home Technologies recommends the following:
• Photographing the installation and copying this checklist for your file.
• That this checklist remain visible at all times on the appliance until the installation is complete.
Comments: Further description of the issues, who is responsible (Installer/ Builder/ Other Trades, etc) and corrective
action needed _____________________________________________________________________________________
_________________________________________________________________________________________________
_________________________________________________________________________________________________
Comments Communicated to party responsible ____________________ by ______________________on ___________
= Contains updated information.
Heatilator • NNXT33-IFT, NNXT33L-IFT, NNXT36-IFT, NNXT36L-IFT Installation Manual • 2628-980 Rev. C • 8/20
AT T E N T I O N I N S TA L L E R:
Follow this Standard Work Checklist
NNXT33-IFT, NNXT33L-IFT
NNXT36-IFT, NNXT36L-IFT
(Builder / Gen. Contractor/) (Installer)
Date Installed:
Location of Fireplace:
Installer:
Dealer/Distributor Phone #
Serial #:
Failure to install appliance according to these instructions could lead
YES
IF NO, WHY?
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
(Date)
2628-982 2/20
3
Advertisement
Table of Contents
