Description; Switch; Removal - DaimlerChrysler SPRINTER2006 Service Manual

VA
POWER WINDOWS

DESCRIPTION

. . . . . . . . . . . . . . . . . . . . . . . . . . 5
OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
WINDOW MOTOR

REMOVAL

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
POWER WINDOWS
DESCRIPTION
The power window system allows each of the door
windows to be raised and lowered electrically by
actuating a switch on each door panel. A master
switch on the drivers door allows the driver to raise
or lower each door window. The power window sys-
tem operates only when the ignition switch is in the
RUN or ACCESSORY position.
OPERATION
WINDOW SWITCH
The power window switches control the battery
and ground feeds to the power window motors. The
passenger door power window switches receive their
battery and ground feeds through the circuitry of the
drivers window switch.
WINDOW MOTOR
Window motors use permanent type magnets. The
B+ and ground applied at the motor terminal pins
will cause the motor to rotate in one direction.
Reversing current through the motor terminals will
cause the motor to rotate in the opposite direction.
Refer to the appropriate wiring information. The
wiring information includes wiring diagrams, proper
wire and connector repair procedures, details of wire
harness routing and retention, connector pin-out
information and location views for the various wire
harness connectors, splices and grounds.
WINDOW MOTOR
REMOVAL
The window motor is serviced with the window
regulator.
POWER WINDOWS
TABLE OF CONTENTS
page
POWER WINDOW SWITCH
DIAGNOSIS AND TESTING - POWER
REMOVAL
INSTALLATION
POWER WINDOW SWITCH
DIAGNOSIS AND TESTING - POWER WINDOW

SWITCH

Test the power window switch continuity. Refer to
the Power Window Switch Continuity chart to deter-
mine if the continuity is correct in the Off, Up and
Down switch positions (Fig. 1).
REMOVAL
(1) Disconnect and isolate the battery negative
cable.
(2) Remove door handle cover.
POWER WINDOWS 8N - 5
WINDOW SWITCH . . . . . . . . . . . . . . . . . . . . . . 5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
. . . . . . . . . . . . . . . . . . . . . . . . . . 6
Fig. 1 POWER WINDOW SWITCH
POWER WINDOW SWITCH CONTINUITY
CHART
SWITCH POSITION
UP
DOWN
NEUTRAL (OFF)
page
CONTINUITY BETWEEN
PIN 1 AND 3
PIN 2 AND 4
PIN 1 AND 4
PIN 2 AND 5
PIN 1AND 3
PIN 2 AND 5