Related Manuals for DaimlerChrysler Dodge Sprinter 2007
Summary of Contents for DaimlerChrysler Dodge Sprinter 2007
- Page 1 • M A I N T E N A N C E S E R V I C E S C H E D U L E • W A R R A N T I E S • R O A D S I D E A S S I S T A N C E • O P T I O N A L S E R V I C E C O N T R A C T S • 2007 DODGE SPRINTER SV0709-E...
- Page 2 DaimlerChrysler recommends that you use this Warranty Start Date Maintenance Service Schedule Book to keep a written record of maintenance performed on your vehicle.
-
Page 3: Table Of Contents
Jeep and Dodge vehicles by DaimlerChrysler Motors Corporation. 5/100 Roadside Assistance Program ....20-23 Chrysler and Dodge are registered trademarks of DaimlerChrysler Canada Inc., a wholly owned subsidiary of DaimlerChrysler Corporation. Jeep is a registered trademark of DaimlerChrysler Corporation, used under Optional Service Contracts ....... -
Page 4: Warranty Information
YOUR RIGHTS AND RESPONSIBILITIES The limited warranties in this booklet are the only express warranties made by DaimlerChrysler Canada Inc. applicable to this WARRANTY vehicle. Any implied warranty or condition of merchantability or fitness for a particular purpose applicable to this vehicle is limited in duration to the duration of these limited warranties. - Page 5 Name or Address Change Card, found in the glovebox packet, to report the change to DaimlerChrysler Canada. If the card is missing, ARRANTY SERVICE ask your retailer for one or “Update Your Personal Information” in Warranty service must be done by an authorized Sprinter Retailer.
-
Page 6: About Your Warranties
The warranties in this booklet cover repairs to factory-installed DaimlerChrysler parts and equipment (that is, DaimlerChrysler parts or equipment installed by DaimlerChrysler or by the selling retailer before the vehicle was delivered to the first owner), if the repairs 2007 Dodge Sprinter... -
Page 7: 3/60 Basic Warranty
Tires are warranted by the tire manu facturers, not by 3/60 BASIC WARRANTY DaimlerChrysler. For details, see the tire manu fac t urer’s warranty If required because of a defect in material or workmanship, the 3/60 booklet in your glovebox. Your Sprinter Retailer may be able to assist Basic Warranty will cover the adjustment, repair or replacement of you if you experience a problem with a factory-installed tire. -
Page 8: 5/100 Powertrain Warranty
5/100 POWERTRAIN WARRANTY / 5/160 DIESEL ENGINE WARRANTY 5/100 POWERTRAIN WARRANTY 5/160 DIESEL ENGINE WARRANTY The following powertrain components are covered for 5 years or These diesel engine parts are covered for 5 years or 160,000 100,000 kilometres, whichever occurs first, measured from the kilometres, whichever occurs first. -
Page 9: Corrosion Warranty
An outer body panel is a sheet metal panel which can not cover replacement parts not supplied by DaimlerChrysler, or be seen while walking around the vehicle, and which is painted body any damage which is caused by the use of non-DaimlerChrysler colour. replacement parts. -
Page 10: Emission Warranty
DaimlerChrysler parts were used; however, denial will not be based the vehicle is, at the time of sale, free from defects in material on the lack of maintenance records alone. - Page 11 EMISSION DEFECT WARRANTY Exhaust: exhaust manifold; oxidation catalyst; turbocharger EMISSION DEFECT WARRANTY Engine Emission Control System Sensor: camshaft position The 3/60 Basic Warranty covers all emission control sensor; crankshaft position sensor/RPM sensor; engine components for 3 years or 60,000 kilometres, whichever occurs control module;...
-
Page 12: What Is Not Covered
DaimlerChrysler specifications. plugs. Required maintenance services are described in detail in Disconnecting, tampering with or changing the reading of the your Owner’s Manual and herein. - Page 13 The warranties in this booklet do not cover parts, equip ment, materials or additives not supplied by DaimlerChrysler or not certified for use on your vehicle. Performance and racing parts are considered to be non-DaimlerChrysler parts.
- Page 14 Government officials or military personnel on assignment functioning of the vehicle. If the warranty is restricted, coverage outside of Canada. may be denied or subject to approval by DaimlerChrysler Canada (See also page 15.) before repairs are performed. 2007 Dodge Sprinter...
-
Page 15: How To Get Service
Canada will continue to be covered by the Basic Warranty.) your warranty, please get a detailed receipt for the work done. When your vehicle returns to Canada, contact the DaimlerChrysler 2007 Dodge Sprinter... -
Page 16: Other Things You Should Know
RODUCTION CHANGES DaimlerChrysler Canada and its retailers reserve the right to make changes in vehicles built and/or sold at any time without in cur ring any obligations to make the same or similar changes on vehicles which were built and/or sold previously. - Page 17 OTHER THINGS YOU SHOULD KNOW ECLAIMED REFRIGERANT ASSETTE TAPES AND CDS To help control suspected ozone-depleting agents, regulations There are some things you should know about cassette require the capture, purification and reuse of automotive refrigerant tapes and non-commercial CDs. Labels applied to tape gases.
-
Page 18: Customer Assistance
❏ Your name, address and phone number CUSTOMER ASSISTANCE ❏ The name of your retailer We want you to be completely satisfied with your DaimlerChrysler ❏ Your Vehicle Identification Number (VIN) vehicle. If you have a warranty or service problem that has not been ❏... -
Page 19: Arbitration
Our goal and that of our retailers is your complete satisfaction. DaimlerChrysler Canada’s participation in CAMVAP makes a valuable contribution to our achievement of that goal. There is no charge for using CAMVAP. CAMVAP results are fast, fair and final, as the award is binding on both you and DaimlerChrysler Canada. -
Page 20: 5/100 Roadside Assistance Program
ROADSIDE ASSISTANCE • NEED A TOW? If your vehicle cannot be driven because of a ROADSIDE mechanical breakdown, it will be towed to the nearest authorized Sprinter Retailer (or to the Sprinter Retailer of your choice, provided it is within a 35-kilometre distance of the point of breakdown). ASSISTANCE •... - Page 21 DaimlerChrysler Canada). Please identify yourself as a Some emissions coverage lasts longer than the Roadside DaimlerChrysler vehicle own er and be ready to provide: Assistance program.* For warranted emission system repairs ❏ Your Vehicle Identification Number after the program expires, towing (only) will be provided on a ❏...
- Page 22 All service providers are independent contractors and are not use is not covered. employees or agents of DaimlerChrysler Canada. Any loss or damage The program does not cover winching or towing for to your vehicle or personal property resulting from providing roadside vehicles that become stuck while plowing snow.
- Page 23 ROADSIDE ASSISTANCE DaimlerChrysler Canada reserves the right to limit services or F YOU HAVE TO PAY reimbursement claims for any vehicle, if in our opinion there is If you have to pay for a service that is normally covered by the...
- Page 24 If you lease a vehicle, you should be aware of your obligation to maintain and repair DAIMLERCHRYSLER the vehicle. DaimlerChrysler Canada Service Contracts can enhance your new vehicle’s factory warranty from the day of delivery and provide CANADA SERVICE mechanical coverage on most major components †...
- Page 25 YOUR RIGHTS AND RESPONSIBILITIES 3. “G ” OWERTRAIN PLANS PLANS Powertrain plans complement the factory powertrain warranty by The most complete protection available for your new vehicle is a providing enhanced roadside coverage and car rental allowance if “Gold Plus” Service Contract which combines the benefits of Gold your vehicle is not drivable and must be kept overnight.
- Page 26 • RANSFERABLE AT NO COST The unexpired portion of the plan coverage may be transferred DaimlerChrysler Service Contracts also provide these addi tional to the subsequent retail purchaser at no cost, within 30 days features and benefits: of the date of sale. (Ask your retailer for details.) •...
- Page 27 (police, ambulance, towing); and motor homes are not eligible for a LIGIBLE VEHICLES DaimlerChrysler Canada Service Contract. DaimlerChrysler Canada vehicles which have 3/60 Basic and/or 5/100 Vehicles used in any competition event, pulling a trailer that Powertrain Warranty and are less than three years in service, and...
- Page 28 The member’s card is to be presented to the retailer when requesting plan services. DaimlerChrysler Canada stands fully behind its service contracts. Be sure that the contract you buy is a genuine DaimlerChrysler Service ’ WNER S RESPONSIBILITY Contract.
-
Page 29: Maintenance Service Schedule
2007 DODGE SPRINTER MAINTENANCE SERVICE SCHEDULE NEXT SERVICE DUE... - Page 30 The limited warranties in the warranty booklet DO NOT COVER repairs affect your warranty rights. With regard to legal required due to improper maintenance. DaimlerChrysler Canada Inc. reserves the right to deny warranty stipulations concerning emissions control, please coverage if the vehicle has not been properly maintained.
- Page 31 Contents 1 Service products 2 Maintenance service 3 Confi rmations Body builder ......21 Introduction ......2 Oil service Plus and maintenance Delivery/handover inspection .
-
Page 32: Introduction
Repair work must be invoiced sepa- ments of your vehicle. necessary specialist knowledge and tools to rately. carry out the work required. DaimlerChrysler In order to ensure that your vehicle contin- Maintenance work will be confi rmed in this recommends that you use an authorized... - Page 33 General Introduction Service A: oil service plus An authorized Sprinter dealer will reset the Your vehicle is equipped with the ASSYST “Active Service System”. This means that service display after every service (oil service plus or maintenance service). the different loads to which the vehicle is subjected during operation, are determined Service B: maintenance service Further information about the ASSYST...
-
Page 34: Warranty
DaimlerChrysler Vans LLC has investigated from DaimlerChrysler Vans LLC to ensure your claim. that your vehicle is inspected and maintained The use of special lubricant additives is not thoroughly and in accordance with the latest recommended. -
Page 35: Service Products
General Service products Service products are: In the event of contact with the eyes, rinse Risk of injury them thoroughly with plenty of clean water. • Fuel Service products constitute a health If any service product is swallowed, consult hazard. They contain toxic and caustic a doctor immediately. -
Page 36: Engine Oil
General Service products In the case of low mileages, change the Engine oil Coolant engine oil and replace the fi lter on diesel The maximum time between changing the engines after no more than 2 years and on Risk of poisoning oil will only be achieved if a particularly gasoline engines after no more than 1 year. - Page 37 General Service products A coolant is added at the factory, which Check the antifreeze/corrosion inhibitor In the event of coolant loss, do not add concentration in the coolant twice a year. ensures adequate antifreeze and anti-corro- water alone, but suffi cient antifreeze/cor- sion protection.
-
Page 38: Brake Fl Uid
General Service products Only used brands which have been tested Brake fl uid and approved – observe the correct boiling point. Risk of poisoning In the course of its service life, the boiling Brake fl uid contains toxic components. point of the brake fl uid will fall due to Should brake fl... -
Page 39: Intervals At A Glance
General Intervals at a glance Perform Maintenance Every (Where time and mileage are listed, follow the interval that occurs fi rst.) Maintenance Item kilometres or months Change the engine oil and engine oil fi lter (diesel engines). 16,000 Change the engine oil and engine oil fi lter (gasoline engines). 16,000 Rotate Tires 16,000... - Page 40 General Intervals at a glance Perform Maintenance Every (Where time and mileage are listed, follow the interval that occurs fi rst.) Maintenance Item kilometres or months Inspect chassis and body U-bolt for proper torque. 48,000 (Only necessary at 1st maintenance service). Replace the engine air cleaner fi...
-
Page 41: Maintenance - Without Assyst Maintenance Computer
General Maintenance – without ASSYST maintenance computer Intervals and engine oil grades Gasoline engine 16,000 Oil Service Plus every 16,000 kilometres Replace vehicle interior dust (air conditioning) fi lter. every 48,000 kilometres 2007 Dodge Sprinter... -
Page 42: Special Maintenance Requirements
General Special maintenance requirements Dust fi lter/Combination fi lter Diesel particle fi lter The dust fi lter for heating/ventilation, rear- The loading of the diesel particle fi lter compartment air conditioning or the air has to be checked for the fi rst time at conditioning combination fi... -
Page 43: Oil Service Plus And Maintenance
Sprinter – Maintenance service Oil service Plus and maintenance service Oil service Plus Maintenance service Checked by after-sales service advisor Vehicle checked for paint, corrosion or accident damage • • Vehicle interior Function check and condition Signalling equipment, indicator lamps •... - Page 44 Sprinter – Maintenance service Oil service Plus and maintenance service Oil service Plus Maintenance service Engine compartment Engine: oil change and fi lter replacement • • Fluid levels checked, corrected if necessary If fl uid is lost, trace and eliminate cause – as a separate order. Engine cooling system: •...
- Page 45 Sprinter – Maintenance service Oil service Plus and maintenance service Oil service Plus Maintenance service Engine by aftersales service advisor Poly-V-belt checked for wear and damage. • Replace dust fi lter for heating/ventilation or active charcoal • /combi fi lter for air conditioning Road wheels, brakes Tire pressures: corrected as necessary, including spare tire •...
- Page 46 Sprinter – Maintenance service Oil service Plus and maintenance service Oil service Plus Maintenance service Vehicle underbody Checks for leak tightness and condition. Checked for abrasion points and correct routing of lines! All assemblies: • • Engine, transmission, axles, steering, power steering pump, brake All lines and hoses •...
-
Page 47: Work In Addition To Engine Oil Replacement
Sprinter – Maintenance service Work in addition to engine oil replacement* At every engine oil change Engine Fuel fi lter with water separator: fuel fi lter replaced *Additional work will be listed and invoiced separately. 2007 Dodge Sprinter... - Page 48 Sprinter – Maintenance service Work in addition to maintenance service* Every 3 years/max 96,000 km Air clean fi lter element renewal (note installation date) At every maintenance service Lubrication work Trailer coupling Chassis and body Trailer coupling: check operation, play and retaining fi xtures Vehicle interior Dust fi...
- Page 49 Sprinter – Maintenance service Work in addition to maintenance service* Every 2 years Hydraulic brake system: brake fl uid renewed For the fi rst time at 144,000 km Loading of the diesel particle fi lter checked, diesel particle fi lter replaced if necessary (page 12) *Additional work will be listed and invoiced separately.
-
Page 50: Special Maintenance Service
Sprinter – Maintenance service Special maintenance service* Every 288,000 km Rear axle: oil change Every 15 years/max 288,000 km Coolant renewed Observe correct coolant composition. *Additional work will be listed and invoiced separately. 2007 Dodge Sprinter... -
Page 51: Confi Rmations
Date Mounting Directives mounting of additional assemblies or superstructures: ■ Special authorization obtained Odometer reading from DaimlerChrysler AG, body approvals department (see Body/ Signature Equipment Mounting Directives) ■ Operating and maintenance instructions for the work/ modifi cations carried out or for assemblies installed have been added to the vehicle’s... - Page 52 Date Mounting Directives mounting of additional assemblies or superstructures: ■ Special authorization obtained Odometer reading from DaimlerChrysler AG, body approvals department (see Body/ Signature Equipment Mounting Directives) ■ Operating and maintenance instructions for the work/ modifi cations carried out or for assemblies installed have been added to the vehicle’s...
-
Page 53: Delivery/Handover Inspection
Confi rmations Delivery/handover inspection Delivery/handover inspection Odometer reading Place Date Signature Stamp of body manufacturer 2007 Dodge Sprinter... -
Page 54: Oil Service Plus/Maintenance Service
Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■... - Page 55 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 56 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 57 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 58 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 59 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 60 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 61 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 62 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 63 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 64 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 65 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 66 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 67 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 68 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 69 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 70 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 71 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 72 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 73 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...
- Page 74 Confi rmations Oil service Plus/Maintenance service/Additional work during maintenance service ■ Date Oil service Plus ■ Maintenance service Odometer reading Repair order no. ■ ■ Replaced Air cleaner Work in addition to engine oil replacement ■ Dust fi lter: heating/ventilation ■...