Checking And Charging The Battery; Checking The Fuses; Adjusting The Throttle Cable Free Play; Replacing The Headlight Bulb (Fz8Na) - Yamaha FZ8NA Service Manual

2. Check:
• Cable operation
Rough movement → Lubricate.
Recommended lubricant
Engine oil or a suitable cable
lubricant
TIP
Hold the cable end upright and pour a few
drops of lubricant into the cable sheath or use
a suitable lubricating device.
EAS20630
ADJUSTING THE THROTTLE CABLE FREE
PLAY
TIP
Prior to adjusting the throttle cable free play,
the engine idling speed and throttle bodies
synchronization should be adjusted properly.
1. Check:
• Throttle cable free play "a"
Out of specification → Adjust.
Throttle cable free play
3.0–5.0 mm (0.12–0.20 in)
2. Adjust:
• Throttle cable free play
▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼
a. Loosen the locknut "1".
b. Turn the adjusting nut "2" in direction "a" or
"b" until the specified throttle cable free
play is obtained.
Direction "a"
Throttle cable free play is increased.
Direction "b"
Throttle cable free play is decreased.
PERIODIC MAINTENANCE
c. Tighten the locknut "1".
EWA39P1301
WARNING
After adjusting the throttle cable free play,
start the engine and turn the handlebars to
the right and to the left to ensure that this
does not cause the engine idling speed to
change.
▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲
EAS21760

CHECKING AND CHARGING THE BATTERY

Refer to "CHECKING AND CHARGING THE
BATTERY" on page 8-186.
EAS21770

CHECKING THE FUSES

Refer to "CHECKING THE FUSES" on page 8-
185.
EAS21790
REPLACING THE HEADLIGHT BULB
(FZ8NA)
1. Remove:
• Headlight top cover bolts "1"
• Headlight top cover "2"
3-30