Table of Contents
Advertisement
1
Important Safety Information
A. Appliance Certification
Model:
Discovery I Wood Appliance
Laboratory:
OMNI Test Laboratories, Inc.
Report No & Date:
061-S-70-6
Type:
Listed Room Appliance, Solid Fuel
Type
Standard:
UL1482 and ULC S627-00 and (UM)
84-HUD, Mobile Home Approved.
The Quadra-Fire Discovery I Wood Appliance meets the U.S.
Environmental Protection Agency's crib wood emission limits
for wood appliances sold after May 15, 2015.
B. BTU & Efficiency Specifications
EPA Certification #: 664
EPA Certified Emissions: 2.1 grams per hour
*LHV Tested Efficiency: 78.7%
**HHV Tested Efficiency: 72.9 %
***EPA BTU Output: 12,000 to 28,800 / hr.
****Peak BTU/Hour Output: 44,000
Vent Size: 6 inches
Firebox Size: 1.4 cubic feet
Recommended Wood Length: 16 inches
Fuel Orientation: Front-to-Back
*Weighted average LHV (Low Heating Value) efficiency using
Douglas Fir dimensional lumber and data collected during EPA
emission test. LHV assumes the moisture is already in a vapor
state so there is no loss in energy to vaporize.
**Weighted average HHV (High Heating Value) efficiency using
Douglas Fir dimensional lumber and data collected during EPA
emission test. HHV includes the energy required to vaporize the
water in the fuel.
***A range of BTU outputs based on EPA Default Efficiency and
the burn rates from the low and high EPA tests, using Douglas
Fir dimensional lumber.
****A peak BTU out of the appliance calculated using the max-
imum first hour burn rate from the High EPA Test and the BTU
content of cordwood (8600) times the efficiency.
C. Mobile Home Approved (USA ONLY)
• This appliance is approved for mobile home installa-
tions in the USA when not installed in a sleeping room
and when an outside combustion air inlet is provided.
• The structural integrity of the mobile home floor, ceil-
ing, and walls must be maintained.
• The appliance must be properly grounded to the frame
of the mobile home with #8 copper ground
• Outside Air Kit, part OAK-ACC must be installed in a
mobile home installation.
NOTE: Hearth & Home Technologies, manufacturer of
this appliance, reserves the right to alter its products, their
specifications and/or price without notice.
Augsut 01, 2016
Fuel Seasoned Cord Wood
wire.
NOTE: This installation must conform with local codes.
In the absence of local codes you must comply with the
UL1482-07, (UM) 84-HUD and NFPA211 in the U.S.A. and
the ULC S627-00 and CAN/CSA-B365 Installation Codes
in Canada. NOT APPROVED FOR MOBILE HOME
INSTALLATIONS IN CANADA!
Improper installation, adjustment, alteration, service or
maintenance can cause injury or property damage.
For assistance or additional information, consult a qualified
installer, service agency or your dealer.
Hearth & Home Technologies WILL NOT warranty appli-
ances that exhibit evidence of over-firing. Evidence of
over-firing includes, but is not limited to:
• Warped air tube
• Deteriorated refractory brick retainers
• Deteriorated baffle and other interior components
D. Glass Specifications
This appliance is equipped with 5mm ceramic glass.
Replace glass only with 5mm ceramic glass. Please con-
tact your dealer for replacement glass.
E. Non-Combustible Materials
Material which will not ignite and burn, composed of any
combination of the following:
- Steel
- Brick
- Concrete
- Glass
Materials reported as passing ASTM E 136, Standard
Test Method for Behavior of Metals, in a Vertical Tube
Furnace of 750° C.
F. Combustible Materials
Material made of/or surfaced with any of the following ma-
terials:
- Wood
- Plant Fibers
- Plywood/OSB
Any material that can ignite and burn: flame proofed or not,
plastered or un-plastered.
7039-174C
Discovery I
- Plaster
- Iron
- Tile
- Slate
- Compressed Paper
- Plastic
- Sheet Rock (drywall)
3
Advertisement
Table of Contents
