Drive Clutch/Driven Clutch Alignment; Fuel Pump; Shock Absorbers (Rebuildable Gas); Standard Track (Zr/Xf) - Arctic Cat XF 7000 Operator's Manual

However, the drive clutch and driven
clutch should be disassembled, cleaned,
and inspected by an authorized Arctic
Cat Snowmobile dealer after every 800
miles of operation or at the end of the
snowmobiling season whichever occurs
first. This service is at the discretion and
expense of the snowmobile owner.
When operating the snowmobile at high
altitudes, it may be necessary to change
certain component parts of the drive
clutch and/or the driven clutch. See an
authorized Arctic Cat Snowmobile dealer
for further information.
CAUTION
DO NOT attempt to service the drive
clutch and driven clutch. The drive
clutch and driven clutch must be ser-
viced by an authorized Arctic Cat
Snowmobile dealer only.
Drive Clutch/Driven
Clutch Alignment
The alignment between the drive clutch
and driven clutch is set at the factory.
Normally, no adjustment is necessary as
long as neither the drive clutch nor the
driven clutch is removed or disassem-
bled. However, if premature drive belt
wear is experienced or if the drive belt
turns over, the drive clutch/driven clutch
alignment must be checked. Take the
snowmobile to an authorized Arctic Cat
Snowmobile dealer for this service. If not
under warranty, this service is at the dis-
cretion and expense of the snowmobile
owner.

Fuel Pump

The fuel pump is designed to provide
adequate amount of gas to the
at all throttle settings. If a fuel delivery
problem is suspected, take the snowmo-
bile to an authorized Arctic Cat Snowmo-
bile dealer. If not under warranty, this
service is at the discretion and expense of
the snowmobile owner.
Shock Absorbers
(Rebuildable Gas)
Each shock absorber should be visibly
checked weekly for fluid leakage, cracks or
breaks in the body/reservoir, or a bent shaft.
If any one of these conditions is detected,
replacement or service is necessary. Take the
snowmobile to an authorized Arctic Cat
Snowmobile dealer for this service. If not
under warranty, this service is at the discre-
tion and expense of the snowmobile owner.
NOTE: When the snowmobile is
operated in extremely cold weather (-
23° C/-10° F or colder), a small
amount of leakage may be present.
Unless the leakage is excessive,
replacement is not necessary.
NOTE: The frequency of servicing
rebuildable shock absorbers will
vary according to the types of condi-
tions and terrain the snowmobile has
been subjected to. If riding quality
deteriorates (or seems to be deterio-
rating), take the snowmobile to an
authorized Arctic Cat Snowmobile
dealer for shock absorber evaluation
and/or servicing. This service is at
the discretion and expense of the
snowmobile owner.
Kits are available to either stiffen or
soften gas shock valving.

Standard Track (ZR/XF)

Accelerated wear strip and track clip
wear caused by operating on ice or hard-
packed snow conditions is NOT covered
under Arctic Cat Inc. warranty policy.
NOTE: If regularly operating on ice
or hard-packed snow conditions,
Performance Wear Strips (p/n 6639-
injectors
448) may be installed at the expense
of the snowmobile owner.
13