Related Manuals for Calomax Cascade-6A
Summary of Contents for Calomax Cascade-6A
- Page 1 Manuals and Documents Brought to you by Wechillit.com Ltd WCI Group House 18 Pride Hill Shrewsbury SY1 1DQ Tel: 01743 289418 Fax: 01743 289416 Web: www.wechillit.com...
- Page 2 MODEL: CASCADE-6A With Power Switch INSTALLATION, OPERATION AND SERVICING INSTRUCTIONS Please read these instructions carefully before operating your boiler for the rst time Calomax Limited Lupton Avenue, Leeds LS9 7DD Tel. 0113 249 6681 Fax. 0113 235 0358 E-mail: service@calomax.co.uk...
-
Page 3: Table Of Contents
CONTENTS INTRODUCTION INTRODUCTION PAGE 3 Thank you for purchasing a Calomax Cascade-6A boiler. All our CHECK LIST products are designed to give years of simple, reliable operation. To ensure this, it is important that the installation and subsequent APPROVALS servicing is carried out by a suitably quali ed engineer in CONSTRUCTION accordance with these instructions. -
Page 4: Construction
CONSTRUCTION COLD WATER INLET All metallic components of the machine, in direct contact with To comply with the U.K. Water Supply Regulation a single check- drinking water are manufactured from high quality 304 grade valve must be tted to the supply. BEFORE CONNECTING, THE stainless steel, or non ferrous materials, providing maximum SUPPLY PIPE MUST BE THOROUGHLY FLUSHED OUT TO resistance to corrosion. -
Page 5: Vent / Overflow
The Wait/Ready light will ash yellow (indicating below temperature) and the unit will slowly ll with water (1.2 L/Min). When water passes The Cascade-6A boiler bene ts from an integral scale inhibitor, this is the low level sensor (just below tap level) the elements will also be not a scale eliminator and its effects will differ according to the water energized. -
Page 6: General Operation
SPARE PARTS GENERAL OPERATION (Refer to centre pages for location). Hold a cup below the tap or place large vessels on the drip • tray. Care must be taken to avoid injury through splashing or over- lling. • To begin lling, pull the handle forward or push it backward –... -
Page 7: Service Instructions
4x pulse. For further assistance, contact our service department on 0113 249 6681 e-mail service@calomax. co.uk. or nd a local service engineer at www.calomax.co.uk Once the rear panel is removed, access to the Service Area has been gained. This access must be restricted to persons having knowledge and practical experience of the appliance, in particular as far as safety and hygiene are concerned. -
Page 8: Exploded Parts View
Exploded parts view If parts required are not identified, please contact (To be read in conjunction with the spare parts list) Calomax Limited (Wrapper not shown for clarity) * Includes nuts, washers, etc. Page 12 Page 13... - Page 9 Failure to remove this The temperature potentiometer (Pot) is pre-set at Calomax and scale and/or moisture could cause the sensor to indicate to will only require adjustment in exceptional circumstances. Contact the PCB that water is covering the elements, whether or not Calomax for advice.
-
Page 10: Accessories
Ingredient caddy Ref: IC3 (3 bay) - as shown IC4 (4 bay) Shelf unit Ref: SHU For more information visit our website at www.calomax.co.uk or call 0113 249 6681 Page 16 Page 17 NB: Not to scale. -
Page 11: Trouble Shooting
BASIC TROUBLE SHOOTING Symptoms Possible Cause Remedy Broken tap top Replace tap top (or component) Normal level sensor De-scale / Clean / Dry holding signal BLACK No boiling water Element(s) cut-out tripped See “Important” note page 13 2.5mm YELLOW / GREEN available Elements failed Replace elements... -
Page 12: Warranty
WARRANTY GUARANTEE (UK Mainland customers only) SERVICE HISTORY AND NOTES Calomax have manufactured water boilers in the UK for over 50 years. We are proud of our products and the back-up service we provide Properly maintained and serviced, a Calomax boiler should last many years and we have no hesitation in providing a full 12 months parts and labour warranty for all models. - Page 13 SERVICE HISTORY AND NOTES SERVICE HISTORY AND NOTES Page 22 Page 23...
- Page 14 50 - 60 Hz Power rating 6kW (max) single phase Note: All measurements are approximate. PLEASE CONTACT OUR SERVICE DEPARTMENT FOR ASSISTANCE Calomax Limited, Lupton Avenue, Leeds LS9 7DD Tel: 0113 249 6681 Fax: 0113 235 0358 e-mail: service@calomax.co.uk Page 24...