Generator Maintenance; Storage; Generator Storage - Champion 100215 Owner's Manual

100215
ENGLISH

Generator Maintenance

Make certain that the generator is kept clean and stored
properly. Only operate the unit on a flat, level surface in
a clean, dry operating environment. DO NOT expose the
unit to extreme conditions, excessive dust, dirt, moisture
or corrosive vapors.
CAUTION
DO NOT use a garden hose to clean the generator.
Water can enter the generator through the cooling
slots and damage the generator windings.
Use a damp cloth to clean exterior surfaces of the generator.
Use a soft bristle brush to remove dirt and oil.
Use an air compressor (25 PSI) to clear dirt and debris
from the generator.
Inspect all air vents and cooling slots to ensure that they
are clean and unobstructed.

Storage

Generator Storage

1. Be sure all appliances are disconnected from the
generator.
2. Start up and run the generator for a short time.
3. Turn the OPD valve on the cylinder to the "Closed"
position.
4. Let the generator run until fuel starvation has
stopped the engine. This usually takes a few
seconds.
5. Turn the fuel valve on the generator to the "Off"
position.
6. The generator needs to cool completely before
cleaning and storage.
7. Disconnect the fuel hose from the LPG cylinder.
8. Clean the generator according to the maintenance
section.
9. Change the oil.
10. Remove the spark plug and pour about 1⁄2 ounce
(14.8 mL) of oil into the cylinder. Crank the engine
slowly to distribute the oil and lubricate the cylinder.
11. Reattach the spark plug.
12. Store the unit in a clean, dry place out of direct
sunlight.
MAINTENANCE AND STORAGE
Generator Storage Cont'd.
DANGER
Generator exhaust contains odorless and colorless
carbon monoxide gas.
To avoid accidental or unintended ignition of your
generator during periods of storage, the following
precautions should be followed:
– When storing the generator for short or extended
periods of time make sure that the LPG cylinder
is disconnected from the generator and the Fuel
Valve is set in the OFF position.
NOTE
– Store LPG tank disconnected from fuel hose and
generator.
– Store LPG tank with the OPD valve in the
"Closed" position.
– Do not store LPG tank in or around extreme
heat. LPG gas is extremely flammable.
– Do not store LPG tank in or around extreme
cold. LPG gas will freeze.
WARNING
Contact with LPG from either the cylinder, excess
from the hose, or from any leaks may cause freeze
burns on skin. Do not touch or spill LPG on bare skin.
WARNING
After a period (short or extended) of non-use
we recommend that you perform the following
maintenance procedures for utmost user safety:
– Check all hoses and fuel lines before each use
for any holes, cracking, abrasions, nicks, cuts, or
any other form of damage. If any hose or fuel line
is found to be damaged in any way, DO NOT use
the unit until the damaged part has been properly
replaced.
– DO NOT try and repair any worn or damaged hose
or fuel line, replace it with a new part ONLY.
– Always check for gas leaks every time a hose
or fuel line is replaced, or disconnected and
reconnected to any fuel fitting. This will ensure
that fuel is properly flowing to the unit and
eliminate possible hazards.
16