Throttle Cable Play; Engine Idle Speed; Fuel Hose - Suzuki LT-A50 Service Manual

THROTTLE CABLE PLAY

Inspect initially at 1 month and every 3 months thereaf-
ter.
Throttle cable play A should be 3 – 5 mm (0.12 – 0.20 in) as
measured at throttle when turning the throttle lightly. If the play A
is incorrect, adjust it as follows:
• Loosen the locknut 1 and turn the adjuster 2 in or out until
the specified play is obtained.
• Tighten the locknut 1 while holding the adjuster 2.
$ Throttle cable play A: 3 – 5 mm (0.12 – 0.20 in)
%
After the adjustment is completed, check that handlebars
movement does not raise the engine idle speed and that
the throttle lever returns smoothly and automatically.

ENGINE IDLE SPEED

Inspect initially at 1 month and every 3 months thereaf-
ter.
• Adjust the throttle cable play. (See above.)
• Warm up the engine.
NOTE:
Make this adjustment when the engine is hot.
• Start the engine, turn the throttle stop screw 1 and set the en-
gine idle speed as follows.
$ Engine idle speed: 1 700 – 1 900 r/min

FUEL HOSE

Inspect initially at 1 month and every 3 months thereaf-
ter. Replace every 4 years.
PERIODIC MAINTENANCE 2-7