freightliner WALK-IN VAN CHASSIS Operator's Manual page 8

Vehicle Identification
Applicable Emissions System Based on Build Date and EPA Regulations
Build Date
From January 1, 2016
* Cummins, Detroit, and Mercedes-Benz ATD's are also equipped with a diesel oxidation catalyst to break down pollutants.
Table 1.1, Applicable Emissions System Based on Build Date and EPA Regulations
EXHAUST AFTERTREATMENT SYSTEM INFORMATION
INDICATOR
LAMP(S)
Indicator Lamp Filter Regeneration
Message(s) Recommended.
Diesel Particulate Filter is reaching
Filter Condition capacity.
Required Action Bring vehicle to
highway speeds to
allow for an
Automatic
Regeneration or
perform a Parked
Regeneration.
For a driver performed Parked Regeneration, vehicle must be equipped with a dash mounted Regeneration Switch.
02/20/2009
A Vehicle Emission Control Information Label indi-
cates compliance with GHG14 regulations. See
Fig. 1.5. It is the owner's responsibility to maintain
the vehicle so that it conforms to EPA and NHTSA
regulations.
03/02/2012
Fig. 1.5, Vehicle Emission Control Information Label
1.3
GHG17: GHG14 components plus OBD16 instrumentation and sensor upgrades, and
component technology that meets NHTSA and EPA 2017 fuel efficiency and
greenhouse gas emission standards (GHG17) requirements.
(Solid) (Flashing)
Level 1 Level 2
Filter
Regeneration
Necessary
Filter is now
reaching maximum
Switch.
capacity.
To avoid engine
derate, bring vehicle
to highway speeds
to allow for an
Automatic
Regeneration, or
perform a Parked
Regeneration as
soon as possible.
Fig. 1.4, ATS Indicators
f080183
Regulation: Emissions Components
CHECK
(Flashing)
Level 3 Level 4
Parked Regeneration Service Regeneration Required.
Required − Engine Engine Derate To Idle Only.
Derate
Filter has reached Filter has exceeded maximum
maximum capacity. capacity.
Vehicle must be Vehicle must be parked, and a
parked, and a Parked Service Regeneration must be
Regeneration must performed. Check engine
be performed. operator's manual for details.
Engine will begin Engine will shut down.
derate.
Certified Clean Idle Label
The California Air Resources Board (CARB) requires
model year 2008 and newer heavy-duty diesel en-
gines to be equipped with a non-programmable en-
gine shutdown system that automatically shuts down
the engine after five minutes of idling in order to limit
emissions of particulate matter and NOx.
Certified vehicles are equipped with a label placed
near the bottom edge of the driver-side door. See
Fig. 1.6.
WARNING
STOP
HEST (High Exhaust
System Temperature)
Flashing
A regeneration is in
progress.
Solid
Exhaust components
and exhaust gas are at
high temperature. When
stationary, keep away
from people and
flammable materials or
vapors.
f080156