Section 5 - Accelerator And Brake Pedal Group; Throttle Input Device Identification; Brake Pedal And Park Brake; Brake Pedal Removal - Club Car DS 2004 Service Manual

SECTION 5 – ACCELERATOR AND BRAKE
PEDAL GROUP
∆
DANGER
• See General Warning, Section 1, Page 1-1.
∆
WARNING
• See General Warning, Section 1, Page 1-1.

THROTTLE INPUT DEVICE IDENTIFICATION

To service and adjust the pedal group properly, the accelerator type must be identified before work begins. All
gasoline DS golf cars use the same type of pedal group; however, electric DS golf cars utilize one of two dif-
ferent accelerator systems: Motor Controller Output Regulator (MCOR) (Figure 5-1, Page 5-1) or a V-Glide
wiper switch (36-volt) (Figure 5-2, Page 5-1). Service and adjustment procedures differ significantly, so it is
important to make sure that the correct procedure is used.
FLOORBOARD REMOVED
FOR CLARITY
Figure 5-1 Electric Vehicle Equipped with MCOR
(Motor Controller Output Regulator)

BRAKE PEDAL AND PARK BRAKE

See General Warning, Section 1, Page 1-1.

BRAKE PEDAL REMOVAL

1. Disconnect the battery cables as instructed. See WARNING "To avoid unintentionally starting..." in
General Warning, Section 1, Page 1-2.
Figure 5-2 Electric Vehicle Equipped with a
V-Glide Wiper Switch (36-Volt)
2004 DS Golf Car Maintenance and Service Manual
5
Page 5-1