Section 2 - Vehicle Specifications - Club Car DS 2004 Service Manual

SECTION 2 – VEHICLE SPECIFICATIONS
SPECIFICATIONS
POWER SOURCE
Engine : 4 cycle, OHV, 286 cc, 9.0 hp rated, single
cylinder, air cooled, with pressure lubrication system
Drive motor: Direct drive, 48 volts DC, series wound,
3.1 hp
Drive motor: Direct drive, 48 volts DC, shunt wound,
3.2 hp
Drive motor: Direct drive, 36 volts DC, series wound,
2.97 hp
Fuel system: Side draft carburetor with float bowl,
fixed jets, fuel filter, and impulse fuel pump
Governor: Automatic ground speed sensing, internally
geared in unitized transaxle
Ignition: Transistor electronic ignition with electronic
RPM limiter
Unitized transaxle: Fully synchronized forward and
reverse with neutral and reduced speed reverse
(11.8:1 forward, 17.1:1 reverse)
Transaxle: Double reduction helical gear with 12.28:1
direct drive axle
Electrical system: Battery - 12 volt, 500 cold cranking
amps at 0°, 650 cranking amps at 32°, 105 minute reserve
and 35 amp charging capacity
Electrical system: 48 volts DC, reduced speed reverse
Electrical system: 36 volts DC, reduced speed reverse
Batteries: High capacity, deep cycle, Trojan PowerDrive
8 volt, 117 min. capacity
Batteries: High capacity, deep cycle, Trojan 6 volt,
115 min. capacity
Charger: Automatic, 48 volt UL and CSA listed
Charger: Automatic, 36 volt UL and CSA listed
Torque converter: Automatic, variable speed, dry type
STEERING/SUSPENSION/BRAKES
Steering: Self-adjusting rack and pinion
Suspension: Front and rear tapered mono-leaf springs
with dual hydraulic shocks
Brakes: Dual rear wheel self-adjusting brakes with cast
iron drums and single brake pedal with automatic-release
park brake
BODY/CHASSIS
Frame/Chassis: Twin I-Beam welded aluminum
Front and rear body: ArmorFlex
Body finish: Matched paint finish over molded-in color
Tires: 18 x 8.5 - 8 tubeless, 4 ply rated
DIMENSIONS/WEIGHT
Overall length
Specifications continued on next page...
GASOLINE
®
91-1/2 in.
(232 cm)
2004 DS Golf Car Maintenance and Service Manual
POWERDRIVE
DS
SYSTEM 48
ELECTRIC
•
•
•
•
•
•
•
•
•
•
•
•
• •
• •
• •
• •
• •
• •
• •
91-1/2 in.
(232 cm)
DS
IQ SYSTEM
36-VOLT
ELECTRIC
ELECTRIC
•
•
• •
•
•
•
•
•
•
• •
• •
• •
• •
• •
• •
• •
91-1/2 in. 91-1/2 in.
(232 cm) (232 cm)
Page 2-1
2