Section 4 - Body And Trim; Cleaning The Vehicle; Seat - Club Car DS 2004 Service Manual

SECTION 4 – BODY AND TRIM
∆
DANGER
• See General Warning, Section 1, Page 1-1.
∆
WARNING
• See General Warning, Section 1, Page 1-1.

CLEANING THE VEHICLE

See General Warning, Section 1, Page 1-1.
CAUTION
• Do not use detergents or cleaning solvents that contain ammonia, aromatic solvents, or alkali
materials on body panels or seats.
• Do not allow battery acid to drip on body panels. Battery acid will cause permanent damage.
Wash spilled battery acid from body panels immediately.
Club Car DS vehicles are equipped with ArmorFlex
automotive cleaners with a sponge or soft cloth for normal cleaning. A garden hose at normal residential
water pressure is adequate.
Club Car does not recommend any type of pressure washing or steam cleaning. Such a process (especially
if the vehicle has an ArmorFlex rear body that is removed) will expose electrical components to moisture.
Moisture entering electrical components can result in water damage and subsequent component failure.
Use non-abrasive wax products. Battery acid, fertilizers, tars, asphalt, creosote, paint, or chewing gum should
be removed immediately to prevent possible stains. See following NOTE.
NOTE: Dispose of waste water properly.

SEAT

To preserve seat appearance, clean regularly with mild soap or detergent applied with a sponge or soft cloth.
Use a soft bristle brush to clean areas that are especially soiled. Use the following guidelines:
Light Soiling: A solution of 10% liquid dish soap and warm water applied with a soft, damp cloth is
recommended. A soft bristle brush may be used if necessary. Wipe off any residue with a water damp-
ened cloth.
Difficult Stains: Dampen a soft, white cloth with a solution of 10% household bleach (sodium
hypochlorite) and 90% water. Rub gently to remove stain, then rinse with a water dampened cloth to
remove bleach concentration.
More Difficult Stains: Perform previous procedure using full-strength bleach, or allow bleach to puddle
on affected area for approximately 30 minutes. Rinse with a water dampened cloth to remove any
remaining bleach concentration. See following CAUTION.
®
front and rear bodies. Use only commercially available
2004 DS Golf Car Maintenance and Service Manual
4
Page 4-1