Ignition Replacement; Ignition Timing; Side Stand Switch Operating Principle - DAELIM ROADWIN VJ125 Service Manual

SIDE STAND SWITCH
OPERATING PRINCIPLE
Elect the main stand to park the motorcycle.
SIDE STAND POSITION
LOWERED
RETRACTED
"Starting" in the table above means "Starting the engine with the starter motor"
REPLACEMENT
IGNITION COIL
IGNITION COIL IGNITION COIL IGNITION COIL IGNITION COIL
IGNITION COIL IGNITION COIL IGNITION COIL IGNITION COIL IGNITION COIL IGNITION COIL
IGNITION COIL IGNITION COIL
IGNITION COIL IGNITION COIL IGNITION COIL
BOLT
BOLT BOLT BOLT BOLT
BOLT BOLT BOLT BOLT
BOLT BOLT BOLT BOLT
BOLT BOLT BOLT

IGNITION TIMING

TIMING LIGHT TIMING LIGHT TIMING LIGHT
TIMING LIGHT TIMING LIGHT TIMING LIGHT TIMING LIGHT
TIMING LIGHT TIMING LIGHT TIMING LIGHT TIMING LIGHT
TIMING LIGHT TIMING LIGHT TIMING LIGHT TIMING LIGHT TIMING LIGHT
TRANSMISSION
NEUTRAL
IN GEAR
NEUTRAL
IN GEAR
IGNITION SYSTEM
Remove the high-tension cord from the plug, remove
the plug cap.
Remove the wire from the ignition coil.
Remove the primary wire from the ignition coil.
Loosen the ignition coil mounting bolt securing the
frame, remove the ignition coil.
Install in the reverse order of removal.
As the system uses the CDI unit, the ignition timing
need not be adjusted. Check the ignition system if
the ignition timing is incorrect.
Warm up the engine.
Stop the engine and remove the AC. generator cap.
Read the instruction for timing light operation.
Connect the timing light to the high-tension cord.
Start the engine and let it idle.
IDLE SPEED : 1,600 100rpm
The ignition timing is correct if the "F" mark aligns
with the index mark on the case.
Increase the engine speed by turning the throttle stop
screw and make sure the "F" mark begins to move
counterclockwise when the the engine speed at
approximately 4,000 rpm.
Install in the reverse order of removal.
CLUTCH LEVER IGNITION
PULLED IN POSSIBLE
RELEASED POSSIBLE
PULLED IN NOT POSSIBLE
RELEASED NOT POSSIBLE
PULLED IN POSSIBLE
RELEASED POSSIBLE
PULLED IN POSSIBLE
RELEASED POSSIBLE
STARTING
POSSIBLE
POSSIBLE
NOT POSSIBLE
NOT POSSIBLE
POSSIBLE
POSSIBLE
POSSIBLE
NOT POSSIBLE
17-5