Toro TM5490 Operator's Manual page 9

1.9 SAFETY PRECAUTIONS 1.9
Preparation continued
Check the mower hydraulic system, particularly the hydraulic hoses, fittings and hose supports. Worn,
crushed or damaged hoses can burst, with risks to health and damage to the machine and surrounding turf
areas.
After refuelling and adding oil to the hydraulic oil tank ensure that the caps are replaced securely.
Check that all linkages, connections and pivot nuts are secure and that wheel nuts are torqued correctly,
refer to SPECIFICATIONS.
Electric lift only:
Check the mower electrical system, particularly the condition of the umbilical cable and electrical connec-
tions between the tractor and the mower. Ensure that the system is in full working order and that the electrical
emergency stop system is fully operational.
Operation
Do not operate the engine in a confined space where dangerous carbon monoxide fumes can collect.
Mow only in daylight or in good artificial light.
Never start the tractor engine with the PTO engaged.
Stored energy devices are charged when the outer wing units are in transport position. Always operate the
relevant lift controls to provide hydraulic support for the wing units suspensions before attempting to release
the transport latches.
Use care when towing:
- Use only approved drawbar hitch points.
- Do not turn sharply.
- Use extreme caution when reversing.
Watch out for traffic when crossing or near roadways.
Disengage the cutterhead drive system before crossing surfaces other than grass.
When using the machine, never direct discharge of material towards bystanders or allow anyone near the
machine while in operation.
Never operate the mower with defective guards, shields or without safety protective devices in place and in
good working order.
Take care whilst manoeuvring in tight turns n forward and reverse gear to avoid contact between the mower
and the tractor.