Air Intake System - BOMBARDIER traxter max series Operator's Manual

When the filter is dried, re-oil with air
filter oil ((P/N 219 700 340) or an equiv-
alent).
Air Filter Installation
Properly reinstall removed parts in the
reverse order of their removal.
Electrical
WARNING
Unless otherwise indicated, al-
ways turn ignition switch to the
OFF position before performing
any maintenance or repair on elec-
trical system.
Battery
WARNING
Never charge a battery while in-
stalled in vehicle.
Removal
Disconnect BLACK (-) cable first then
RED (+) cable.
WARNING
Always respect this order for dis-
assembly; disconnect BLACK (-)
cable first. Electrolyte or fuel va-
pors can be present in engine
compartment and a spark may
ignite them and possibly cause
personal injuries.
Remove the holding straps.
Pull out vent tube from frame.
Remove battery from vehicle being
careful not to tilt it so that electrolyte
flows out of vent tube.
Battery electrolyte is a caustic
substance that burns or destroys
organic tissues by chemical ac-
tion.
skin and clothing. Wear protec-
tive eyeglasses and a suitable pair
of non-absorbent gloves when
removing the battery by hand.
Should any electrolyte spillage oc-
cur, immediately wash off with a
solution of baking soda and water.
Cleaning
Clean battery, battery casing, cables
and battery posts using a solution of
baking soda and water.
Remove corrosion from battery cable
terminals and battery posts using a
firm wire brush. Battery top should be
cleaned by soft brush and any grease-
cutting soap or baking soda solution.
Refilling
Place battery on a level surface.
Unscrew caps and add distilled water
up to upper mark as required. Do not
overfill.
V00G02Y
1. Upper mark
Properly retighten caps.
Installation
Reinstall battery in vehicle. Fasten
battery and make sure to reinstall the
vent tube.
_____________________
WARNING
Avoid contact with eyes,
1
135