Battery Cleaning - Ezgo RXV 646285 Owner's Manual

Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
Hand held watering devices available at an automotive parts
store, or automatic watering devices like the one included in
the E-Z-GO Battery Maintenance Kit (P/N 25587G01) can be
used with an approved water supply. These watering devices
are accurate, easy to use and allow for fast fill. They also
keep the correct electrolyte level within the battery cells.
The watering device must only be used if the electrolyte
level is less than 1/2" (13 mm) above top of plates.
The electrolyte in a battery is an acid solution which can cause severe burns to the skin and eyes.
Clean all electrolyte spills to the body and eyes with clear water. Contact a physician immediately.

Battery Cleaning

To prevent battery damage, make sure you correctly install all battery caps.
To decrease the risk of damage to vehicle or floor, neutralize acid before you spray the battery with water.
To decrease the risk of damage to the electrical components while cleaning, do not use a pressure washer.
Clean the batteries according to the Periodic Service Schedule.
When you clean the battery cases and terminals, do not use a water hose without neutralizing any acid deposits first. The
water hose moves the acid from the top of the batteries to another area of the vehicle or storage facility, where it can
cause damage. After spraying the batteries, a conductive residue remains on the batteries and contribute to the dis-
charge of the batteries
To clean an electrolyte spill, use a solution of 2 teaspoons (10 ml) sodium
bicarbonate (baking soda) mixed with 1 quart (1 liter) of water.
Always wear a safety shield or approved safety goggles when you add
Owner's Guide
Watering gun similar to the type included in the
Battery Maintenance Kit
Electrolyte Level
Pure Water
water or charge the batteries.
MAINTENANCE
Valve consistently
fills to a predetermined
level
Single Battery Cell
B
49