Hauling; Service And Maintenance - Ezgo RXV 646285 Owner's Manual

Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.

Hauling

Make sure you secure the vehicle and all items before you transport a vehicle on a trailer.
Do not allow any people on a vehicle being transported on a trailer.
Remove the windshield before you transport a vehicle on a trailer.
Maximum speed with sun top installed is 50 mph (80 kph).
If you transport the vehicle on a trailer at highway speeds, the sun top must be removed and the seat bottom secured.
When you transport the vehicle on a trailer below highway speeds, check for tight hardware and cracks in sun top at the
mounting points.
The rated capacity of the trailer or truck must be more than the weight of the vehicle and load plus 1000 lbs. (454 kg).
See GENERAL SPECIFICATIONS for the weight of the vehicle.
Secure the vehicle to the trailer with ratchet tie downs.

SERVICE AND MAINTENANCE

Read all notices, cautions and warnings in this manual before you do any type of service opera-
The drive wheels must be lifted and supported on jack stands before you do any service to the
To decrease the risk of motor damage, do not operate the vehicle at full throttle for more than 5
Disconnect the negative battery cable before you service the vehicle to prevent accidental opera-
To decrease the risk of electrical arc, which can cause a battery explosion, dis-
able all electrical loads from the battery before you remove the battery wires.
Use wrenches with insulation to decrease the risk of a short-circuit if a wrench falls across the bat-
tery terminals. A battery short-circuit can cause an explosion.
The electrolyte in a battery is an acid solution which can cause burns to the skin and eyes. Com-
pletely clean all electrolyte spills that contact the body and eyes with clear water. Contact a physi-
Neutralize electrolyte spills with a solution of 2 teaspoons (10 ml) sodium bicarbonate (baking
soda) mixed in 1 quart (1 liter) of water. Clean with water.
Be careful when you use the aerosol containers near battery terminals. Use a metal container that
powertrain when the motor is in operation.
seconds with the drive wheels lifted off the ground.
Wear eye protection when you service the vehicle. Be careful when you do
work around batteries, use solvents or compressed air.
cian immediately.
has insulation to prevent an explosion.
tions.
tion.
Owner's Guide
MAINTENANCE
B
43