Advertisement
Table of Contents
Advertisement
Table of Contents
Related Manuals for Nu-Vu RM-4T
Summary of Contents for Nu-Vu RM-4T
- Page 1 For NU–VU® Models: RM-4T RM-5T RA-4T RA-5T OWNER'S MANUAL NU-VU 5600 13 STREET MENOMINEE, MICHIGAN 49858-1029 (906) 863-4401 FAX (906) 863-5889 November 2009...
-
Page 3: Table Of Contents
RM/RA SERIES TABLE OF CONTENTS ABOUT YOUR NUVU® EQUIPMENT ............WARRANTY ....................RECEIPT AND INSTALLATION ..............START–UP ....................11 OPERATING INSTRUCTIONS ..............12 MAINTENANCE AND CLEANING GUIDE ..........14 SERVICE AND REPLACEMENT GUIDE ........... 16 REPLACEMENT PARTS LIST ..............16 ELECTRICAL SCHEMATICS .............. -
Page 5: About Your Nuvu® Equipment
RM/RA SERIES OWNER'S MANUAL ABOUT YOUR NUVU® EQUIPMENT NUVU® units are in use throughout the United States and Canada and have been exported to other parts of the world. NUVU® continually modifies and updates its equipment to improve the capabilities as new innovations become available. This enables the user to obtain better and more useful results. - Page 6 Using the same footprint but different internal configurations the following models are offered: RM-4T - 4 pan oven with manual controls, 5” pan spacing. RM-5T - 5 pan oven with manual controls, 4” pan spacing. RA-4T - 4 pan oven with programmable controls, 5”...
-
Page 7: Warranty
RM/RA SERIES OWNER’S MANUAL NVUV® EQUIPMENT WARRANTY NVUV® products are warranted against defects in workmanship and materials. No other express warranty, written or oral, applies. No person is authorized to give any other warranty or assume any other liability on behalf of NVUV®, except by written statement from an officer of NVUV®. Your NVUV®... -
Page 8: Warranty Limitations
RM/RA SERIES OWNER'S MANUAL NVUV® STANDARD TIME ALLOWANCES FOR WARRANTY REPLACEMENTS CHANGE PERFORMED CHANGE TIME TEST TIME TOTAL TIME Oven Motor/Rebalance Fan 1 hr. ½ hr. 1½ hr. Oven Heating Element 1 hr. ½ hr. 1½ hr. Control Circuit Board ½... -
Page 9: Receipt And Installation
RM/RA SERIES OWNER’S MANUAL Insufficient or incorrect voltage Damage to electrical components caused by a power surge or spike Incorrect installation (i.e., separate neutral and ground not supplied, or incorrect location of high-voltage power leg for 240-volt 3-phase units) ... -
Page 10: Installation Procedures
RM/RA SERIES OWNER'S MANUAL RECEIPT: It is essential to inspect the unit immediately when it arrives. NUVU® has placed instructions on the packaging to help avoid damage in transit. However, accidents or negligent handling can produce hidden damage. These steps should be followed: A. - Page 11 RM/RA SERIES OWNER’S MANUAL #1 Installation A qualified installer or electrician should remove the Top Panel of the unit to expose the power terminal connections. A copy of the unit wiring schematic is attached to the inside of the unit near the power terminal connections.
- Page 12 RM/RA SERIES OWNER'S MANUAL The oven should be connected according to all national and local electrical codes, either through a plug-type connection or direct wiring. All connections must be made with COPPER WIRE ONLY in the correct gauge for the application. Provide enough slack in the wiring to allow for equipment to be moved about during installation and any future required servicing.
-
Page 13: Start-Up
RM/RA SERIES OWNER’S MANUAL unit positioning and service. Avoid any kinks or strains on the tubing and place the tubing where it will not be damaged in any way. The tubing end that attaches to the unit must not be damaged or deformed in any way. The cut end should be cut straight and clean with no deforming of the tubing. -
Page 14: Operating Instructions
RM/RA SERIES OWNER'S MANUAL Close the Oven Door securely. The Motor/Blower Wheel should restart. G. Set the Oven Temperature Control to 350F. The Temperature Control Indicator Light should illuminate and the Oven should begin heating. You may continue with the Oven Start-Up and even begin the Proofer Start-Up while the Oven heats. - Page 15 RM/RA SERIES OWNER’S MANUAL D. As soon as the product is finished open the Oven Door and remove the product quickly. Immediately close the Oven Door to minimize temperature loss. INTERNAL STEAM OPTION: This option uses a push-and-release Steam Switch to activate an internal interval timer along with a Solenoid Valve.
-
Page 16: Maintenance And Cleaning Guide
RM/RA SERIES OWNER'S MANUAL F. The product will be maintained at the set hold temperature until you remove it from the Oven, change the setting on the Hold Control or turn the Oven OFF. NOTE: If you desire to pre-heat your Oven before loading any product the 24– Hour Timer must be set for enough time to pre-heat your unit to the desired temperature. - Page 17 RM/RA SERIES OWNER’S MANUAL CAUTION: DO NOT USE ABRASIVE CLEANERS ON THE DOOR OR YOU MAY SCRATCH THE GLASS!!! • The Oven interior should be wiped out daily. Remove the Oven Element Cover once a month for inspection and cleaning (if you have the INTERNAL STEAM option you should remove, inspect and clean the element Cover weekly): 1) Remove the thumbscrews along the top edge and pull the Element Cover down.
-
Page 18: Service And Replacement Guide
RM/RA SERIES OWNER'S MANUAL SERVICE AND REPLACEMENT GUIDE Your RM/RA series model has been designed to be serviced quickly and easily. In fact, any individual who has average mechanical ability can do the work. Our Service Department is also available to you Monday through Friday from 7:00 a.m. to 5:00 p.m. (Central Standard Time) should you find yourself with a situation or problem. -
Page 19: Door Components
RM/RA SERIES OWNER’S MANUAL RM SERIES COMPONENTS: Contactor ………………………………………………………...... 66-2017 Temperature Control ..................252-5008 Control Knob ..................252-2003 Temperature Control Sensor ................252-3001 Temperature Control Indicator Light 230V ………………………… ..... 50-0030 Timer, 60-Minute 230V 50hz …………………………………… ....252-1020 Timer, 60-Minute 230V 60hz …………………………………… ....252-1019 Timer Knob .................... - Page 20 RM/RA SERIES OWNER'S MANUAL NUVU® MENOMINEE, MICHIGAN 49858 page 18 SALES FAX (906) 863-5889 • SERVICE FAX (906) 863-6322 (906) 863-4401...
- Page 21 RM/RA SERIES OWNER’S MANUAL NUVU® MENOMINEE, MICHIGAN 49858 (906) 863-4401 SALES FAX (906) 863-5889 • SERVICE FAX (906) 863-6322 page 19...