Operation; Use And Care - Garland HEEGM24CE Installation And Operation Manual

USE AND CARE

Operation

IF FOR ANY REASON YOU SMELL GAS, BEFORE, DURING OR
AFTER OPERATION, TURN THE POWER OFF AND CLOSE THE
MANUAL SHUT-OFF VALVE TO THE APPLIANCE. CONTACT
AN AUTHORIZED SERVICE AGENT FOR SERVICE BEFORE
ATTEMPTING TO RESTORE GAS SUPPLY. FOR A LIST OF
AUTHORIZED SERVICE AGENTS, PLEASE REFER TO THE
MANITOWOC FOODSERVICE WEB SITE AT http://www.
ManitowocFoodservice.com
1. To turn on and use this appliance, the operator simply
needs to turn on the power switch(es).
2. Models HEEGM24CE and HEEGM36CE have one power
switch on the lower right side of the unit. Once pushed
to the "ON" position, gas is supplied to all the burners. At
the same time a spark is supplied to each burner to ignite
the gas. Sparking occurs for a pre-determined amount of
time (approx. 4 seconds) and then stops.
BURNERS
ON/OFF
At this time all burners should be lit. To verify, each
burner fl ame can be inspected visually through view
holes in the valve panel. Also, the indicator light above
the switch will be illuminated if ignition of all burners
is successful. If ignition of all burners is unsuccessful,
the indicator light will shut off and gas valve will
automatically close. The unit will wait a set amount of
time (approx. 15 seconds) and then attempt ignition
again. If ignition is unsuccessful a second time the unit
will go into lockout. To take the unit out of the lockout
mode, turn the power switch to the "OFF" position and
remove power to the unit.
Part # 4532435 Rev 02 (Sep 9/14)
SINGLE SWITCH
Ignition can be attempted again by turning the power
switch to the "ON" position and restoring power to the
unit. IMPORTANT: Wait 5 minutes between ignition
attempts. If ignition fails again and the unit goes back
into lockout, turn the power off and have a qualifi ed
service technician inspect the unit.
3. Models HEEGM48CE and HEEGM60CE have two power
switches on the lower right side of the unit. Once
pushed to the "ON" position, they operate in the same
manner as the single switch, except they allow the
operator to run the left and right side of the broiler
independently as shown below:
• HEEGM48CE: The left switch operates burners 1 to 4
on the left side of the unit. The right switch operates
burners 5 to 9 on the right side of the unit. The entire
unit runs when both switches are used.
• HEEGM60CE: The left switch operates burners 1 to 6
on the left side of the unit. The right switch operates
burners 7 to 11 on the right side of the unit. The
entire unit runs when both switches are used.
LEFT SIDE
BURNERS
ON/OFF
4. It is recommended that the unit run for approximately 30
minutes on start up to reach the desired temperature.
5. For temperature adjustment, each burner has a control
knob which will adjust the height of the fl ame from a
high to a low position.
6. To shut off the unit, the operator simply needs to turn off
the power switch(es). When shutting down for longer
periods of time, it is best to also close the manual shut-
off valve to the unit.
DOUBLE SWITCH
RIGHT SIDE
BURNERS
ON/OFF
Page 9