Checking The Front Brake Pads; Checking The Rear Brake Pads - Yamaha XV19SX(C) Service Manual

2. Remove:
• Rider seat
Refer to "GENERAL CHASSIS" on page 4-1.
3. Check:
• Brake fluid level
Below the minimum level mark "a" → Add the
recommended brake fluid to the proper level.
Front brake
Recommended fluid
DOT 4
Rear brake
Recommended fluid
DOT 4
B
A. Front brake
B. Rear brake
EWA13090
WARNING
• Use only the designated brake fluid. Other
brake fluids may cause the rubber seals to
deteriorate, causing leakage and poor
brake performance.
• Refill with the same type of brake fluid that
is already in the system. Mixing brake fluids
may result in a harmful chemical reaction,
leading to poor brake performance.
• When refilling, be careful that water does
not enter the brake fluid reservoir. Water
will significantly lower the boiling point of
the brake fluid and could cause vapor lock.
ECA13540
CAUTION:
Brake fluid may damage painted surfaces
and plastic parts. Therefore, always clean up
any spilt brake fluid immediately.
NOTE:
In order to ensure a correct reading of the brake
fluid level, make sure the top of the brake fluid
reservoir is horizontal.
4. Install:
EAS21250

CHECKING THE FRONT BRAKE PADS

The following procedure applies to all of the
brake pads.
1. Operate the brake.
2. Check:
a
EAS21260

CHECKING THE REAR BRAKE PADS

The following procedure applies to all of the
brake pads.
1. Operate the brake.
2. Check:
3-22
• Rider seat
Refer to "GENERAL CHASSIS" on page 4-1.
• Front brake pad
Wear indicator grooves "1" almost disap-
peared → Replace the brake pads as a set.
Refer to "FRONT BRAKE" on page 4-35.
• Rear brake pad
Wear indicators "1" almost touch the brake
disc → Replace the brake pads as a set.
Refer to "REAR BRAKE" on page 4-47.
CHASSIS
1