Winnebago 2006 Outlook Operator's Manual
  1. Manuals
  2. Brands
  3. Winnebago Manuals
  4. Motorhomes
  5. 2006 Outlook
  6. Operator's manual
Winnebago 2006 Outlook Operator's Manual

Winnebago 2006 Outlook Operator's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
About this Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-1
Safety Messages Used in this Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-1
Owner InfoCase . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-2
Chassis Owner's Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-2
Pre-Delivery Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-2
Front Axle Tire Alignment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-2
Service and Assistance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-2
Reporting Safety Defects . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-2
Vehicle Certification Label . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-3
Body and Chassis Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-4
Tank Capacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-6
Owner Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-7
Emergency Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-7
2006 New Vehicle Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-8
General Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-1
Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-1
Formaldehyde Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-1
LP Gas Leak Detector. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-1
Carbon Monoxide Warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-2
Carbon Monoxide Alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-2
Smoke Alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-3
Fire Extinguisher . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-3
Emergency Exits. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-4
Roadside Emergency . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-4
Jump Starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-6
Engine Overheat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-6
Effects of Prolonged Occupancy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-6
Front Seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-1
Folding Dinette Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-1
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-1
Child Restraints . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-2
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-3
Keyless Entry System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-3
Mirrors - Exterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-3
Rearview Monitor System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-3
Battery Boost Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-4
Auto Air Conditioner/Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-4
In-Dash Radio. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-4
Engine Access. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-5
Engine Cooling System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-5
Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-5
Rev. 0614060911

TABLE OF CONTENTS

September 2006
Copyright 2006 Winnebago Industries, Inc. All rights reserved.
Part No. 132000-03-006

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 2006 Outlook and is the answer not in the manual?

Questions and answers

Related Manuals for Winnebago 2006 Outlook

Summary of Contents for Winnebago 2006 Outlook

  • Page 1: Table Of Contents

    Tires ................3-5 Rev. 0614060911 September 2006 Part No. 132000-03-006 Copyright 2006 Winnebago Industries, Inc. All rights reserved.
  • Page 2 Table of Contents Suspension Alignment and Tire Balance ..........3-5 Rear Air Springs .
  • Page 3 Table of Contents PLUMBING 7 Fresh Water System ............. 7-1 Water Pump .
  • Page 4 Table of Contents Plastic Parts - Cleaning ............11-2 Exterior Lights .

  • Page 5: Introduction

    Winnebago personal injury. Industries beyond the standard written warranty as presented in this manual.

  • Page 6: Owner Infocase

    If you need warranty repairs while traveling you may take your motor home to any authorized Winnebago or Itasca dealership and request their CHASSIS OWNER’S MANUAL assistance. Throughout this manual, frequent reference is See the dealership directory in your Owner made to the vehicle chassis owner’s manual that...

  • Page 7: Vehicle Certification Label

    1. Chassis manufacturer. and fuel economy. 2. Chassis manufacture date. 9. Rear Axle Wheel Configuration: Single or 3. Month and year of manufacture at Winnebago Dual as it relates to the inflation. Industries. 10. Serial Number: This is the serial number 4.

  • Page 8: Body And Chassis Specifications

    SECTION 1 INTRODUCTION BODY AND CHASSIS SPECIFICATIONS Model 322E 322R 324V 325F 326A Length (Bumper to Bumper) Ford 22’ 1” 22’ 1” 24’ 9” 25’ 11” 27’ 3” Chevy 25’ 7” 26’ 9” 28’ 1” Exterior Height w/AC Ford 11’ 0” 11’...
  • Page 9 SECTION 1 INTRODUCTION BODY AND CHASSIS SPECIFICATIONS Model 327L 329B 329K 331C 332G Length (Bumper to Bumper) Ford 28’ 0” 29’ 11” 29’ 11” 31’ 5” 32’ 0” Chevy 28’ 10” 30’ 9” 30’ 11” 32’ 2” Exterior Height w/AC Ford 11’...

  • Page 10: Tank Capacities

    SECTION 1 INTRODUCTION TANK CAPACITIES Chassis Fuel Tank Ford 22’ models ............. .37 gal. Ford 24’-32’...

  • Page 11: Owner Information

    Motor Home Serial Number _____________________________________________________________ Vehicle Chassis Identification No (VIN) ___________________________________________________ Vehicle Mileage at Time of Delivery ______________________________________________________ Selling Dealer Name and Address ________________________________________________________ ___________________________________________________________________________________ EMERGENCY INFORMATION YOUR WINNEBAGO INDUSTRIES DEALER Name _______________________________________________________________________________ Address _____________________________________________________________________________ ___________________________________________________________________________________ Contact Person _______________________________________________________________________ Phone ______________________________________________________________________________...

  • Page 12: 2006 New Vehicle Limited Warranty

    Winnebago Industries, Inc. of Forest City, Iowa warrants each new Winnebago Industries motor home to the owner for use in the U.S.A. and Canada as follows: WINNEBAGO INDUSTRIES’ RESPONSIBILITY...
  • Page 13 CHANGES IN DESIGN Winnebago Industries, Inc. reserves the right to make changes in design and changes or improvements upon its products without imposing any obligation upon itself to install the same upon its products theretofore manufactured.

  • Page 15: Safety/Precautions

    SECTION 2 SAFETY/PRECAUTIONS • Driving through water deep enough to wet the brakes may affect stopping distance or cause GENERAL WARNINGS the vehicle to pull to one side. Check brake • Only seats equipped with seat belts are to be operation in a safe area to be sure they have occupied while the vehicle is moving.

  • Page 16: Carbon Monoxide Warning

    SECTION 2 SAFETY/PRECAUTIONS CARBON MONOXIDE WARNING WARNING Avoid inhaling exhaust gases, as they contain carbon monoxide, which is a colorless, odorless and poisonous gas. LP Gas Leak Detector The best protection against carbon monoxide entry into the vehicle body is a properly maintained engine exhaust and ventilation system.

  • Page 17: Smoke Alarm

    SECTION 2 SAFETY/PRECAUTIONS Press button to test Press button to test Smoke Alarm Carbon Monoxide Alarm Further Information Further Information See the manufacturer’s information in your Please read the information provided by the Owner InfoCase for further instructions on manufacturer, which is included in your Owner battery replacement and testing of the smoke InfoCase.

  • Page 18: Emergency Exits

    SECTION 2 SAFETY/PRECAUTIONS WARNING WARNING Do not test the fire extinguisher by This window should be kept closed while discharging it. Partial discharge can driving to avoid drawing dangerous cause leakage of pressure or contents exhaust gases into the vehicle. which would render the unit inoperative when needed.

  • Page 19: Recovery Towing

    • Let the vehicle coast to a stop, gently steering to a safe stopping place off the traffic lanes of Winnebago Industries does not assume responsibility for damage incurred while towing the road. Don’t worry about damaging the tire this vehicle.

  • Page 20: Jump Starting

    SECTION 2 SAFETY/PRECAUTIONS JUMP STARTING EFFECTS OF PROLONGED OCCUPANCY If your coach will not start from the automotive batteries, try using the battery boost Your motor home was designed primarily for switch to divert power from the coach batteries to recreational use and short term occupancy.

  • Page 21: Driving Your Motor Home

    SECTION 3 DRIVING YOUR MOTOR HOME The information in this section refers only to features installed or adapted to the dash and driver compartment area by Winnebago Industries. It also includes passenger seating in the living area of the coach.

  • Page 22: Child Restraints

    SECTION 3 DRIVING YOUR MOTOR HOME Adjustment: CHILD RESTRAINTS To lengthen belt, turn tongue at a right angle to belt and pull to desired length. To shorten, pull A properly installed and secured child loose end of belt. restraint system can help reduce the chance or severity of personal injury to a child in an To Fasten: accident or during a sudden maneuver.

  • Page 23: Keys

    SECTION 3 DRIVING YOUR MOTOR HOME Tether Anchor Loop Mirror Heat Switch Mirror Adjustment Control KEYS Your motor home is supplied with several sets Mirror Heaters of keys. In addition to the chassis manufacturer’s The mirrors also contain heating elements to ignition key, you receive keys for the entrance defog or de-ice the mirror glass during cold door and exterior compartment doors.

  • Page 24: Battery Boost Switch

    SECTION 3 DRIVING YOUR MOTOR HOME BATTERY BOOST SWITCH This switch can be used to provide emergency starting power from the motor home auxiliary battery if the automotive battery is discharged. Please refer to the radio manufacturer’s oper- ating guide in your Owner InfoCase for detailed instructions on programming preset station but- tons and using this full-featured radio/audio sys- tem.

  • Page 25: Engine Access

    SECTION 3 DRIVING YOUR MOTOR HOME Radio Power Switch SUSPENSION ALIGNMENT The radio power switch lets you connect the AND TIRE BALANCE dash radio to the coach batteries with the ignition switch turned off for listening while parked. This The front suspension and steering system of prevents accidental draining of the chassis (start- this vehicle was factory aligned using highly ing) battery with prolonged use of the radio.

  • Page 26: Lights

    SECTION 3 DRIVING YOUR MOTOR HOME • Store or secure all loose items inside the motor Air Spring Valves home before traveling. Possible over- looked items such as canned goods or small appliances on the countertop, cooking pans on the range, or free-standing furniture items can become dangerous projectiles during a sudden stop or evasive maneuver.

  • Page 27: Roof Loading

    SECTION 3 DRIVING YOUR MOTOR HOME Weighing There is typically a scale operator to direct CAUTION you but the basic routine is to take three separate weights - front axle, whole vehicle, and rear axle. You will first drive only your front wheels onto The weight of the loaded vehicle the scale pad, then drive ahead so that the whole (including options, attachments,...

  • Page 28: Car Or Trailer Towing

    SECTION 3 DRIVING YOUR MOTOR HOME Label. The front and rear axle weight also should The load on each wheel or dual-wheel set not exceed the corresponding Axle Weight should not exceed one-half of the corresponding Rating specified on the Vehicle Certification GAWR.

  • Page 29: Trailer Wiring Connector

    SECTION 3 DRIVING YOUR MOTOR HOME listed Gross Weight Ratings. See “Vehicle Certification Label” in the Introduction Section for information on gross weight ratings. CAUTION Towing will affect vehicle handling, durability and fuel economy. Exceeding any of Exceeding any of the recommended the listed Gross Weight Ratings will result in gross vehicle weight ratings may result in unacceptable overall vehicle performance.

  • Page 30: Towing Guidelines

    (GCWR): are independent of towing vehicle ratings.) This is the maximum allowable weight of the NOTE: Some Winnebago Industries models motor home and loaded trailer, including the equipped with a Class 3 hitch may have items noted in GVWR above. The “trailer” can...

  • Page 31: Tool & Ladder Storage

    SECTION 3 DRIVING YOUR MOTOR HOME CAUTION Observe the engine temperature gauge more frequently than normal. If Awning Tool overheating occurs, pull off to the side of Storage the road and allow the engine to (typical) thoroughly cool before refilling the radiator and restarting the engine.
  • Page 32 Roof Ladder Extension -Model 325F with Rear Storage Trunk Roof Ladder Extension Storage To use the ladder extension: • See the general ladder instructions above, but follow these additional steps • Pivot the upper support pad of the ladder extension outward into place as indicated in the photo and insert both side pins.

  • Page 33: Storage Compartment Doors

    SECTION 3 DRIVING YOUR MOTOR HOME CAUTION Always store the ladder extension before Hook traveling. extension onto bottom rung. STORAGE COMPARTMENT DOORS Lower extension The high-density gaskets used on the exterior against storage compartments are designed to provide a backwall more positive seal against dust and weather.

  • Page 35: Appliances & Equipment

    SECTION 4 APPLIANCES & EQUIPMENT Leveling The appliances installed in your motor home are manufactured by reputable RV appliance Before operating the refrigerator when the makers and have been tested by independent motor home is stationary, place a small level on laboratories to meet all applicable standards and the freezer plate and make certain the unit is codes set for RV appliances.

  • Page 36: Refrigerator Service Access Compartment

    SECTION 4 APPLIANCES & EQUIPMENT REFRIGERATOR SERVICE RANGE AND OVEN ACCESS COMPARTMENT (Exterior) The exterior refrigerator compartment allows access to the rear of the refrigerator for inspection, maintenance and service. The range and oven in your motor home operate on LP gas. Avoiding Asphyxiation The following warning label has been located in the cooking area to remind you to provide an...

  • Page 37: Microwave Oven

    SECTION 4 APPLIANCES & EQUIPMENT RANGE HOOD WARNING The range hood vent draws cooking odors and airborne grease particles into the filtration grid and recirculates the air or vents it to the outside of Portable fuel-burning equipment the coach. A light on the underside of the hood including wood and charcoal grills and stoves, should not be used inside the provides illumination for food preparation.

  • Page 38: Water Pump Switch

    SECTION 4 APPLIANCES & EQUIPMENT Tank Capacities start the auxiliary generator or turn on the water pump and water heater. Indicator lights tell you if See “Tank Capacities” in Section 1. the water pump is on or if the water heater pilot light is out.

  • Page 39: Water Heater

    SECTION 4 APPLIANCES & EQUIPMENT WATER HEATER PRESSURE-TEMPERATURE RELIEF VALVE Operating Instructions On occasion, water may be seen seeping from the water heater pressure temperature relief Read the Water Heater Manufacturer’s valve. This is no cause for repair or replacement Installation and Operation Manual for complete of the valve.

  • Page 40: Water Heater By-Pass Valve

    SECTION 4 APPLIANCES & EQUIPMENT LP GAS FURNACE Start Up: Open 1. Open the LP gas tank valve by turning fully counterclockwise. 2. Move thermostat switch from OFF to HEAT and press the Temp Selector button (Up/Down arrows) until the desired temperature is shown on the display.

  • Page 41: Heat Pump

    SECTION 4 APPLIANCES & EQUIPMENT To Shut Down: efficiency of the heat pump. The heat pump will not operate when the outside temperature falls 1. Slide thermostat switch to OFF position. below 36 degrees F. 2. Close LP tank valve. NOTE: Metal coatings used during manufacture To operate the heat pump: of the furnace burner parts may smoke when...

  • Page 42: Ducted Roof Air Conditioning System

    SECTION 4 APPLIANCES & EQUIPMENT DUCTED ROOF AIR CONDITIONING SYSTEM The furnace thermostat also controls ducted roof air conditioner operation when the thermostat switch is placed in ‘cool’ position. All cooling functions controlling to setpoint have a short cycle protection time delay of 3 minutes.

  • Page 43: Thermostat Operation

    SECTION 4 APPLIANCES & EQUIPMENT Thermostat Operation The following chart shows the system functions with the “Heat/Cool” thermostat. Disregard refer- ences to heat functions when using the “Cool Only” thermostat in the rear bedroom.

  • Page 44: Manual Entrance Step

    SECTION 4 APPLIANCES & EQUIPMENT MANUAL ENTRANCE STEP ELECTRIC ENTRANCE STEP -Optional To extend the entrance step, lift up on the front of the step and pull out until it drops into position. The power switch for the electric entrance step To retract, lift up on front of step and push back is located to the left of the main entry door as you until step locks into travel position.
  • Page 45 SECTION 4 APPLIANCES & EQUIPMENT Stationary Extended Mode - Step Switch OFF (Step Remains Extended) With the Step power switch in the OFF position the step will extend when the screen door is opened and will stay extended whether the door is opened or closed. This position is normally used to keep the step extended when parked at a campsite or whenever people will be entering and exiting the vehicle...

  • Page 47: Lp Gas

    SECTION 5 LP GAS LP GAS SUPPLY WARNING The LP gas system supplies fuel for the range, water heater, furnace and refrigerator (while in Do not alter or remove LP tank gauge at gas mode). When used and handled properly, this any time.

  • Page 48: Safe Use Of The Lp Gas System

    SECTION 5 LP GAS NOTE: If you travel outside the U.S. with your motor home, you may find butane or DAN GE R propane/butane mixtures available in addition to propane. Because gas- burning RV appliances are designed to DO NOT FILL CONTAINER TO MORE run on propane only, we recommend that THAN 80 PERCENT OF CAPACITY.

  • Page 49: Lp Gas Warnings And Precautions

    SECTION 5 LP GAS immediately. Have the LP gas system checked by your dealer or other qualified LP gas LP GAS WARNINGS AND service center. PRECAUTIONS • Do not tamper with the LP gas piping system, It is illegal for vehicles equipped with LP pressure regulator or gas appliances.

  • Page 50: Pressure Regulator

    SECTION 5 LP GAS • Never use an open flame to test for LP gas leaks. Replace all protective covers and caps on LP system after filling. Make sure valve is closed and door latched securely. • Portable fuel-burning equipment, including wood and charcoal grills and stoves, shall not be used inside the recreational vehicle.
  • Page 51 SECTION 5 LP GAS In very cold weather when a large volume of gas is being used for heating, it is possible to experience a loss of gas pressure. At first, this problem may appear to be caused by a regulator freeze-up, but is actually caused by failure of the liquid gas to vaporize as fast as it is needed.

  • Page 53: Electrical

    SECTION 6 ELECTRICAL Your coach is equipped with an electrical 110-volt current to 12-volt DC current. All system consisting of two separate voltages; a 12- equipment in the motor home that is normally volt DC system and a 110-volt AC system. The powered by the auxiliary batteries is then 12-volt system consists of two internal power powered through the converter.

  • Page 54: Power Center

    SECTION 6 ELECTRICAL Park Fuses or Breakers Most campgrounds are equipped with a fuse or circuit breaker at the receptacle. This protects the park’s wiring, as well as the power cord on your vehicle, from electrical damage. If electrical power fails, contact the park attendants and have them check the fuse or breaker for your supply receptacle.

  • Page 55: 110-Volt Circuit Breakers

    SECTION 6 ELECTRICAL NOTE: The converter will not change 12-volt NOTE: The power converter section will auto- DC current to 110-volt AC. matically route 12-volt lights and motors to battery power in this event. Current drawn from the coach batteries passes through the power converter unchanged, The thermal overload will reset itself after a although it is routed through a series of protective...

  • Page 56: 110-Volt Receptacles (Outlets)

    SECTION 6 ELECTRICAL 110-VOLT RECEPTACLES WARNING (OUTLETS) A number of standard AC electrical outlets are The GFCI will not completely eliminate provided throughout the coach for connecting electrical shock. Small children and small appliances such as televisions, radios, persons with heart conditions or other toasters, etc.

  • Page 57: 12-Volt Dc System

    SECTION 6 ELECTRICAL Operation Warnings and Cautions WARNING The exhaust of all internal combustion engines contains carbon monoxide (CO). This poisonous gas is colorless, odorless, tasteless, and lighter than air. The exhaust systems of both your motor home engine and your generator engine have been installed with your safety in mind.

  • Page 58: Auxiliary Battery Switch

    SECTION 6 ELECTRICAL Converter See “Power Center”. Chassis (Starting) Battery The chassis battery is used to operate the engine starter and automotive accessories and controls found on the instrument panel. The slideout room systems and the electric step are also connected to the chassis battery. The chassis battery is located in the engine compartment.

  • Page 59: Battery Care

    SECTION 6 ELECTRICAL drain by electrical items that are hooked directly and insufficient charge are to: to the coach batteries, such as clock displays and 1. Turn off the Auxiliary Battery switch to avoid radio memories, etc. parasitic discharge (the trickle discharge Always leave this switch ON except during caused by directly connected components like storage periods.

  • Page 60: 12-Volt House Fuses And Circuit Breakers

    SECTION 6 ELECTRICAL • Neutralize corrosion buildup or acid film on top of battery by washing with a baking soda/ WARNING water solution. Rinse with clear water. NOTE: Make sure vent caps are on securely to To prevent wiring damage, it is essential prevent baking soda solution from enter- when replacing the cables on the battery, ing the battery and contaminating the...

  • Page 61: Volt Fuse Panel

    SECTION 6 ELECTRICAL 12-Volt Fuse Panel The fuse panel is on the right-hand side of the power converter. 12-Volt House Fuses The fuse panel accepts only blade type plug-in fuses. Always replace fuses with those of the same amperage rating. Bad Fuse Good Fuse Battery Charge Meter...

  • Page 63: Plumbing

    SECTION 7 PLUMBING faucets and toilet. A check valve built into the pump prevents water from entering the pump and FRESH WATER SYSTEM filling the water tank. The fresh water system provides water to the galley sink, shower, bathroom lavatory, toilet and To Connect to an External City Water water heater.

  • Page 64: Water Pump

    SECTION 7 PLUMBING To Disconnect from the City Water Unscrew bowl and remove to clean strainer Source: 1. Turn the city water source off. 2. Open a faucet inside the vehicle to relieve line pressure. 3. Disconnect the hose from the vehicle and replace the cap on the city water connection.

  • Page 65: Disinfecting Fresh Water Systems On Rv's

    SECTION 7 PLUMBING 4. Open all faucets, hot and cold. then a 100 ppm chlorine concentration should 5. Turn on pump switch. be permitted to stand in the system for at least 6. Close each faucet as it begins to deliver a 1 hour.

  • Page 66: Toilet

    SECTION 7 PLUMBING • The wash station is located in the water service center on the left side of the coach. Important “Don’ts” • Don't use facial tissue or regular toilet tissue in the RV toilet. These will not disintegrate sufficiently and will often cling to the sides of the holding tank.

  • Page 67: Holding Tank Level Indicators

    SECTION 7 PLUMBING sink and shower, and may include bathroom NOTE: We recommend that you dump all lavatory. See Tank Capacities in Section 1 for holding tanks before traveling to avoid your model. carrying unnecessary weight. Dumping Holding Tanks Using On-Site Sewer Hook-Ups 1.

  • Page 68: Holding Tank Heater

    SECTION 7 PLUMBING HOLDING TANK HEATER WATER LINE AND TANK DRAIN VALVES - Optional The water drain valves are used to drain water Your coach may be optionally equipped with from the water tank and the water supply lines black water and grey water holding tank heaters when preparing the motor home for storage or to allow use of waste utilities in freezing when sanitizing the water system.

  • Page 69: Winterizing Procedure

    30 psi or less to force air through the system. (A “blow-out” 4. Turn on water pump and open all sink faucets plug can be purchased at any Winnebago or and shower head knobs. Leave open after Itasca dealer. P/N 701705-01-000.) water stops flowing.
  • Page 70 SECTION 7 PLUMBING CAUTION CAUTION Limit air pressure to 30 psi to avoid Leave by-pass valve handle in NORMAL damage to pump or water lines. FLOW position if draining water and blowing out water lines. Place in BYPASS position ONLY when using antifreeze NOTE:DO NOT burst air into the system.
  • Page 71 SECTION 7 PLUMBING • Turn the diverter valve handle so that it points holding tanks. Although these products toward the suction tube. may have a deodorizing effect, they may damage plastic and rubber parts in the • Turn the water pump switch on. system.

  • Page 72: Water System Drain Valve Locations

    SECTION 7 PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS MODEL SYSTEM DRAIN VALVE LOCATIONS 322R Water Lines: Two (2) valves beneath front dinette seat. Lift seat board to access. Two (2) valves behind the removable face panel of the shower pan base. Water Tank: One (1) valve beneath couch.
  • Page 73 SECTION 7 PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS MODEL SYSTEM DRAIN VALVE LOCATIONS 324V (with rear Water Lines: Two (2) valves beneath shower. Access through removable bed) panel on lower front of shower cabinet. Two (2) valves 326A beneath bed. Lift mattress to expose access hole. Water Tank: One (1) valve beneath the bed.
  • Page 74 SECTION 7 PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS MODEL SYSTEM DRAIN VALVE LOCATIONS 325F Water Lines: Two (2) valves beneath galley. Lift bottom shelf to access. Water Tank: One (1) valve beneath galley. Lift bottom shelf to access. Water Heater: Drain plug on outside of coach, behind service door.
  • Page 75 SECTION 7 PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS MODEL SYSTEM DRAIN VALVE LOCATIONS 329B Water Lines: Two (2) valves beneath shower. Access through removable 329K panel on lower front of shower cabinet. One (1) valve in drivers side 2nd storage compartment. Water Tank: In drivers side 2nd storage compartment.
  • Page 76 SECTION 7 PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS MODEL SYSTEM DRAIN VALVE LOCATIONS 332G Water Lines: Two (2) drains at foot of bed on drivers side. Exterior Close valves under bed head drivers side. Move mattress to Shower: expose hole. Tank Drain: Move mattress to expose hole at head of bed.

  • Page 77: Entertainment

    SECTION 8 ENTERTAINMENT Components SWING-OUT TV MOUNTS Each component has a set of buttons that lets you select which source you want to get the picture signal from, whether cable TV, roof antenna, digital satellite dish, VCR/DVD or CAUTION whatever equipment you have connected to the AUX input.

  • Page 78: Front Tv Ignition Switch Interlock

    SECTION 8 ENTERTAINMENT • VCR = Connects selected TV to the VCR/ DVD player. 12-VOLT TV/DVD POWER SWITCH • CABLE = Connects to a local cable TV system hookup if you have connected one to Side Swing-Out TV your coach. The TV and DVD player unit on models with side-mounted swing-out TV are powered by 12- FRONT TV IGNITION SWITCH...

  • Page 79: Tv Antenna

    SECTION 8 ENTERTAINMENT • Turn the inverter off when not in use to avoid connected to cable. The antenna draining the coach battery. amplifier will make the cable TV signal snowy. NOTE:Batteries will deplete quickly with use of the inverter. The inverter is intended for To operate amplifier, turn on power switch.

  • Page 80: Cable Tv Hook-Up

    See your authorized Winnebago Industries compartment door or ensuring that an dealer for proper installation and sealing of roof awning will prevent entrance of mounted components.

  • Page 81: Two-Way Radios

    SECTION 8 ENTERTAINMENT Further Information See the radio manufacturer’s information in your Owner InfoCase for radio and CD operating instructions TWO-WAY RADIOS - Optional If your coach is equipped with the available two-way radios, the charger/docking bay is located on a cabinet end near the entrance door - for easy access as you head out the door.

  • Page 83: Furniture & Softgoods

    SECTION 9 FURNITURE & SOFTGOODS SLEEPING FACILITIES WARNING Do not use sleeping facilities while vehicle is moving. Front Overhead Bunk OVERHEAD FRONT BUNK Shown with bunk sections and (If equipped) ladder in use position The overhead front bunk is located above the Straps are provided on the mattress section to driver’s compartment.

  • Page 84: Dinette/Bed Conversion

    SECTION 9 FURNITURE & SOFTGOODS DINETTE/BED CONVERSION Dinette to Bed: 1. Release the catch on the table leg brace and fold the leg up against the bottom of the table. Bed to Dinette: 1. Reattach the table onto the wall support and lower the table leg.

  • Page 85: U-Shaped Dinette/Bed Conversion

    SECTION 9 FURNITURE & SOFTGOODS Reverse steps to reassemble to dinette U-SHAPED DINETTE/BED configuration. CONVERSION Round Table Leaf Extension - Optional (Model 327L only) Lift the leaf extension upward then reach The round dinette can be converted into beneath the tabletop and slide the support arms additional sleeping space when needed by outward to hold the extension.

  • Page 86: Quartz Wall Clock

    Pull the lower and upper People are drawn to the natural beauty of sections down together or separately. wood. At Winnebago Industries, our craftsmen work with the art found in each piece of wood to create cabinets of superior quality, backed by the QUARTZ WALL CLOCK Winnebago Industries warranty.
  • Page 87 SECTION 9 FURNITURE & SOFTGOODS light. Color differences or changes in wood can also be caused by exposure to harsh chemicals, extreme heat or other contributing external conditions. Any color change that occurs in both the finish and the wood is considered part of the natural aging process and is not to be considered defect or damage.

  • Page 89: Slideout

    SECTION 10 SLIDEOUT Travel Strap SLIDEOUT ROOM OPERATION The travel strap must be released before ex- tending the room or damage to the coach will re- The slideout living room provides a spacious sult. living area at the push of a button. The slideout The travel strap is designed only to help keep room is extended and retracted using a motorized the room extension secured against the coach...
  • Page 90 SECTION 10 SLIDEOUT Press to Retract Press to Extend To Fasten Strap: • When the room has reached its full extension • Hook the strap end peg into the mooring it will stop automatically. bracket. • To stop the room during operation, release the •...

  • Page 91: Troubleshooting

    SECTION 10 SLIDEOUT Problems Retracting the Room To Retract the Slideout Room Set the Park Brake if the red Park Brake light flashes while pressing the Retract button. See Operation Safety Precautions before proceeding. To retract the room, press and hold the “IN” Green light will flash button.

  • Page 92: Emergency Retraction

    SECTION 10 SLIDEOUT only if there is not a motor failure or full electrical system failure. To override the encoder and enter the Manual Mode, press and hold the RESET button until the two LEDs begin to flash. While in the Manual Mode each of the two, room slide arms are activated by pressing and holding the IN and OUT buttons.
  • Page 93 SECTION 10 SLIDEOUT Type B - Single Arm - cover mounted beneath It may be necessary to move the handle face of slideout room: Remove the four bolts that slightly from side to side to fit it onto the shaft. fasten the cover to the arm - two on each side.
  • Page 94 SECTION 10 SLIDEOUT • Crank the room in until it is just ‘snugged up’. 3. Attach the shaft extension to hex-end shaft Do not overcrank or you could damage the and place the ratchet wrench onto the hex end gear assembly. shaft, then insert into the hole in the bed base as shown.

  • Page 95: General Slideout Care

    SECTION 10 SLIDEOUT GENERAL SLIDEOUT CARE • Wipe outer seals occasionally with talc or 303 brand protectant for smooth quiet operation. • Clean the floors inside before retracting the room to avoid vinyl flooring scratches or carpet pile snags. • See your authorized dealer for regular maintenance and service of the slideout mechanism.

  • Page 97: Maintenance/Storage

    Have the sealant replaced if you notice any of needless weight to the vehicle. This, in effect, the above. Your local Winnebago Industries reduces the amount of cargo you can carry and dealer has the correct and necessary parts and remain within GVWR and GAWR limits.

  • Page 98: Exterior Finish

    Appropriate compounds are sold at • Do Not use any aromatic solvents such as Winnebago and Itasca dealers, and the materials acetone, MEK, toluene, xylene, etc., on are quickly and easily applied. Also, inspect decals. Any solvent including alcohol may weather seals around door, etc., and if necessary...

  • Page 99: Exterior Lights

    Use the following cautionary lists as a guide when selecting EXTERIOR LIGHTS cleaning products to use on plastic parts. Most Winnebago Industries vehicles have polycarbonate lenses on exterior lamps, which are very sensitive to a variety of chemical CAUTION solvents and cleaners.

  • Page 100: Vinyl Fabrics

    SECTION 11 MAINTENANCE/STORAGE NOTE:To minimize fading of upholstery, carpets and other interior fabrics caused by excessive sunlight, the drapes, blinds or shades should be closed when the motor home is parked for an extended period of time. WARNING When cleaning upholstery and fabric, do not use lacquer thinner, nail polish remover, laundry soaps, or bleach.

  • Page 101: Care Of Ceiling Fabric

    SECTION 11 MAINTENANCE/STORAGE CARE OF CEILING FABRIC While using your coach, your ceiling fabric Most commercially available carpet and may become soiled and require spot cleaning upholstery cleaners will do an excellent job from time to time. The following information is removing stains.

  • Page 102: Cabinetry

    SECTION 11 MAINTENANCE/STORAGE Water Stains TABLES AND COUNTERTOPS Water stains should be cleaned with a mixture of 1/4 cup of white powdered or clear liquid Work surfaces are covered with a plastic laundry detergent (no coloring) in a bucket of laminate that resists solvents, stains and warm water.

  • Page 103: Range And Refrigerator

    SECTION 11 MAINTENANCE/STORAGE Mineral Based Stains. Cleaners designed to To tighten the tension remove iron or rust should not harm the sink, nor Wrap the lower end of the guide cords (on will solvents such as denatured alcohol, mineral each side of the shade) a few turns around the spirits or acetone.

  • Page 104: Removal From Storage

    SECTION 11 MAINTENANCE/STORAGE Clean and Prep Coach for Storage materials and compounds can be purchased from your dealer. Badly damaged weather 1. Turn off the LP gas tank seals may need to be replaced by your dealer. 2. Turn the furnace thermostat switch OFF. 10.
  • Page 105 SECTION 11 MAINTENANCE/STORAGE 14. Check tires for proper cold inflation pressure. See Vehicle Certification Label. 15. After washing accumulated winter grime from the vehicle, it is important to carefully inspect the seams and sealants for separation or cracks that may have appeared around the window frames, vents and any other joints.

  • Page 106: Coach Maintenance Chart

    SECTION 11 MAINTENANCE/STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. LP System Have LP system checked for leaks. Pressure regulator - inspect and adjust if needed Check LP tank condition, mounting and fittings Electrical System...

  • Page 107: Safety Equipment

    SECTION 11 MAINTENANCE/STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items Headlights, Taillights and Marker Lights Turn Signals Horn...
  • Page 108 SECTION 11 MAINTENANCE/STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants Inspect Replace Frame & Chassis Follow Chassis manufacturer’s maintenance guide (Refer to Chassis Operating Guide) Inspect Hitch Receiver (if towing)

  • Page 109: Recommended Sealant Application

    SECTION 11 MAINTENANCE/STORAGE RECOMMENDED SEALANT APPLICATION 11-13...
  • Page 111 Index 110-Volt AC System....6-1 Engine Overheat ..... . 2-6 110-Volt Circuit Breakers.
  • Page 112 Index Range and Oven ..... . 4-2 Water System Drain Valve Locations ..7-10 Range and Refrigerator ....11-7 Weighing Your Loaded Vehicle .

Table of Contents

Save PDF