Drain Pump Removal - Electrolux EIDW6105GS0 Technical & Service Manual

C C o o m m p p o o n n e e n n t t T T e e a a r r d d o o w w n n
D D r r a a i i n n P P u u m m p p R R e e m m o o v v a a l l
The drain pump pulls water from the sump to drain
the dishwasher. This pump is a wet rotor style and
is mounted with two screws to the bottom of the
sump.
The drain pump can be checked for resistance at
the electronic control. The normal resistance for
the drain motor is 21.5 ohms.
To remove the drain pump:
1. Pull unit from its installation position. Lay unit
on its back.
2. Remove the base tray.
3. Using a flat bladed screwdriver, loosen the
tubing clamp from the output end of the drain
pump. Pull tubing from drain pump.
Use a pliers to remove the spring clamp from
the tubing connected to the drain inlet.
(See Figure 5-40)
N N O O T T E E : : If unit was operated prior to service, water
may be present in the tubing. Have a towel or
absorbent material on hand when servicing water
system components.
4. From the underside of the drain pump, push
back the retaining clip with a small flat bladed
screwdriver and pull electrical connection from
drain pump.
5. Using a #20 Torx bit, extract the two screws
securing drain pump to the sump.
6. To remove the drain pump and bracket, first
pull drain pump down away from inlet tubing
until the bracket is free of the upper grommet
and pump is free of the inlet tubing. Then slide
pump and bracket to the left until free of the
right side grommet.
7. Remove the mounting bracket from drain
pump by using a phillips head screwdriver and
extracting the screw that secures the mounting
bracket to the drain pump. (See Figure 5-41)
8. The drain pump has a cover over the pumping
chamber that can be removed for cleaning.
Extract the three screws securing the cover to
the drain pump.
9. The cover can be pulled from the drain pump
body. Make sure to clean the o-ring before
reassembly.
Tubing
Clamps
Electrical
Connection
F F i i g g u u r r e e 5 5 - - 4 4 0 0 . . D D r r a a i i n n P P u u m m p p R R e e m m o o v v a a l l
Mounting
Bracket
Screw
F F i i g g u u r r e e 5 5 - - 4 4 1 1 . . D D r r a a i i n n p p u u m m p p B B r r e e a a k k d d o o w w n n
4-20
Screws
Screws
Electrical
Connection