SDMO BOOSTER 2000 UK Maintenance Manual page 7

Before use, it is essential that you know how to stop the generating set immediately and that
you thoroughly understand all the controls and operations.
Warning
Never let other people use the generating set without giving them all necessary instructions beforehand.
Never let children touch the generating set, even when it is not in operation. Do not operate the generating set
near animals (as it could cause them to panic).
Never start the motor without an air filter or exhaust.
Never invert the positive and negative battery terminals (if fitted) when connecting them. Such an inversion can
lead to severe damage to the electrical equipment.
Never cover the generating set with any type of material while it is in operation or just after it has been turned
off. Wait until the motor is cold.
Never coat the generating set with oil in an attempt to protect it from corrosion. Some preservative oils are
flammable. Also, some are dangerous to inhale.
In all cases, respect the local regulations currently in place concerning the use of generating sets.
1.3.3 Safeguards against electrocution
While they are in operation, generating sets produce electric current.
Connect the generating set to earth each time you use it, in order to prevent electrocution.
Danger
Never touch stripped cables or disconnected connectors.
Never handle a generating set with wet hands or feet.
Never expose the equipment to liquid splashes or rainfall, and do not place it on wet ground. Always keep the
electrical cables and the connections in good condition.
Do not use equipment in a poor state of repair which could lead to electrocution or damage to the equipment.
Use a differential protection device between the generating set and the appliances if the cable or cables used are
more than 1 metre in length.
Use flexible, durable cables, with rubber sheathing, conforming to the IEC 60245-4 standard or equivalent
cables.
Do not connect the generating set to other power sources, such as the mains. In specific cases where there is
provision for a reserve connection to existing electrical networks, this must only be carried out by a qualified
electrician, who should take the operating differences of the equipment into account, according to whether the
mains or generating set is being used.
Special circuit breakers designed for use with generating sets are used to prevent electrocution. If these circuit
breakers need to be replaced, circuit breakers with identical nominal ratings and specifications must be used.
1.3.4 Safeguards against fire
Keep all inflammable materials (e.g.: petrol, oil, fabric etc.) out of the way when the generating
set is in operation.
The motor should not be operated in areas containing explosive products. There is a risk of
sparks forming where all electrical and mechanical components are not shielded.
Danger
1.3.5 Safeguards against exhaust gases
Exhaust gases contain carbon monoxide, which is a highly toxic substance. This substance can
cause death if it is present in excessive concentrations in the air inhaled.
For this reason, always use the generating set in a well ventilated area, where gases will not be
able to accumulate.
Danger
Good ventilation is required for your generating set to work properly. Without this, the motor would very
quickly run at too high a temperature, which could lead to accidents or damage to the equipment and to
surrounding items. However, if it is necessary to operate it inside a building, adequate ventilation must be
provided, so that people and animals are not affected. It is imperative that exhaust gases are discharged outside.
3/12 Ref. GPAO : 33522111701 Ref. Const. 5490 326 5000