Suggestions To Prevent Theft; Maintenance; Scheduled Maintenance Chart - MOTO GUZZI Norge 1200 Use & Maintenance Book

6
C
A
A 1
NOTE u Load your weight onto the centre stand
Do not rest the side stand to
lever (6) (Pos. B) and move your centre
ground. Keep the vehicle upright.
of gravity to the back of the vehicle
u Push down the side stand (5) with your
(Pos.C).
right foot and extend it completely.
u Push onto centre stand lever (6) (Pos.
A) and rest it onto the ground.
Make sure that the vehicle is stable.
CAUTION
Fold up the side stand.
u
Proceed with care.
The positioning of the vehicle on the
centre stand may be difficult, since the
vehicle is very heavy. Release the
handgrip (1) and handle (4) only when
the vehicle is steady on the stand.
SUGGESTIONS TO PREVENT

MAINTENANCE

THEFT
NEVER leave the key in the ignition switch
and always use the steering lock.
Fire hazard.
Park the vehicle in a safe place, possibly in
K e e p f u e l a n d o t h e r f l a m m a b l e
a garage or a protected place.
s u b s t a n c e s a w a y f r o m e l e c t r i c
When possible, use an additional antitheft
components.
device.
Before proceeding to service or inspect
Make sure you have all the necessary
of the vehicle, stop the engine and
documents with you and that the excise tax remove the key from the ignition, wait
has been paid.
for the engine and the exhaust system
to cool down and, if possible, lift the
Write your personal data and telephone
v e h i c l e u s i n g a d e q u a t e l i f t i n g
number in this page to help trace the
equipment placed on firm and level
vehicle back to you in the event it is stolen
ground.
and subsequently recovered.
Ensure the area is well ventilated before
proceeding.
SURNAME: ...............................................
Be careful not to touch hot engine and
exhaust system parts that might burn
you.
NAME: .......................................................
Do not put any vehicle parts into your
mouth: vehicle components are not
ADDRESS: ................................................
edible and some of them are harmful or
even toxic.
..................................................................
Unless expressly indicated otherwise,
TELEPHONE NO.: .................................... r e a s s e m b l y i s a r e v e r s a l o f t h e
disassembly procedure.
Wear latex gloves during servicing.
NOTE
Recovered vehicles are often
Normally, scheduled maintenance can be
traced back to the owner thanks to his/her
carried out by the owner, although some
details recorded in the Owner's Manual.
operations may require specific tools and
technical training.
62
use and maintenance Norge 1200
4
B
6
B
WARNING
use and maintenance Norge 1200
For periodic maintenance, servicing or
WARNING
technical advice, contact a Moto Guzzi
Authorised Dealer, who will ensure prompt,
accurate service.
Ask your Moto Guzzi Authorised Dealer to
carry out a road test after a repair or
scheduled maintenance operation.
In addition, perform the "Pre-ride checks"
after each maintenance operation, see
page 52 (PRE-RIDE CHECKS CHART).
NOTE
This vehicle is equipped with an
electronic engine control unit capable of
detecting abnormal operation in real time
and storing faults.
Any time the ignition switch is set to
the light " " on the instrument panel
!
comes on for three seconds.
CAUTION
If the alarm LED " " and the "
!
SERVICE" diagnosis icon come on
during engine normal operation, it
means that the control unit has detected
CAUTION
a failure. In most cases, the engine will
keep running, although giving less
performance. Immediately contact a
Moto Guzzi Authorised Dealer.

SCHEDULED MAINTENANCE CHART

OPERATIONS TO BE CARRIED OUT BY THE Authorised Dealer Moto Guzzi (CAN ALSO BE CARRIED OUT BY THE OWNER).
Component
Outer spark plugs (*)
Engine oil filter (*)
Fork
Light operation/beam setting
Lighting system
Safety switches
Brake fluid
Engine oil
Tyres
Tyre pressures (**)
Battery terminals tightening
Head bolts tightening
Engine oil pressure warning light
Brake pad wear
Drain fluid from oil drain tube from air box
= check and clean, adjust, lubricate or change, if necessary;
Perform maintenance operations more frequently than the indicated intervals if you are riding in rainy or dusty conditions, on rough road
surfaces or when the vehicle is used for racing.
(*) = If vehicle is used in competitions, change every 5000 km (3125 mi).
(**) = Check every two weeks or at the specified intervals.
61
OPERATIONS TO BE CARRIED OUT BY THE Moto Guzzi Authorised Dealer.
Component
Gearbox fluid
Idle mixture (CO)
Bowden cables and controls
Steering bearings and steering play
Wheel bearings
Brake discs
Air filter
Vehicle operation
,
Brake systems
Brake fluid
Fork fluid
Fork oil seals
!
Brake pads
Valve clearance adjustment
Wheels / tyres
Nut, bolt, screw tightening
Battery terminals tightening
Cylinder synchronisation
Suspensions and trim
= check and clean, adjust, lubricate or change, if necessary (as specified in the Workshop Manual);
Halve maintenance intervals if you are riding in rainy or dusty conditions, on rough road surfaces or when the vehicle is used for racing.
(*) = If vehicle is used for racing, check every 5000 km (3125 mi).
64
use and maintenance Norge 1200
End of running-in Every 10000 km Every 20000 km
[1000 km (625 mi)] (6250 mi) or 12 months (12500 mi) or 24 months
at every start-up:
before each ride and every 2000 km (1250 mi):
every 5000 km (3125 mi):
= clean; = change; = adjust.
use and maintenance Norge 1200
End of running-in Every 10000 km Every 20000 km
[1000 km (625 mi)] (6250 mi) or 12 months (12500 mi) or 24 months
after the first 10000 km (6250 mi) and then every 20000 km (12500 mi):
after the first 30000 km (18750 mi) and then every 20000 km (12500 mi):
every 2000 km/1250 mi: - if worn:
= clean; = change; = adjust.
63