Cleaning The Air Filter Element - Yamaha 2006 FJR1300AS Service Manual

b. Start the engine.
c. Shift the transmission from neutral to 1st gear
and back to neutral ten times.
d. Shift the transmission into 1st gear, and then
apply the rear brake.
NOTE:
If the engine stalls, restart the engine, let it idle
for at least 90 seconds, and then repeat steps (c)
and (d).
L LLL L LLL L L LLL L
3. Check:
• Starting-off performance of vehicle
Abnormal vehicle vibration/abnormal start-
ing-off performance/sudden acceleration
compared to before the hydraulic clutch sys-
tem was serviced → Select diagnostic code
No. Sh_ _66 in the diagnostic mode and op-
erate the hand shift lever switch (shift up) two
times.
Refer to "Diagnostic code table (Diagnostic
code No. Sh_ _66)".
M MMM M MMM M M MMM M
a. Place the vehicle on the centerstand.
b. Start the engine and warm it up until at least
three segments appear on the coolant tem-
perature meter "1" as shown in the illustra-
tion.
c. Shift the transmission into 1st gear, and then
slowly turn the throttle grip and check that the
rear wheel rotates.
d. Check that the transmission can be shifted
into 2nd gear.
e. Shift the transmission into neutral, and then
raise the centerstand.
f. Shift the transmission into 1st gear, and then
slowly turn the throttle grip and check the
starting-off performance of the vehicle.
L LLL L LLL L L LLL L
EAS20920

CLEANING THE AIR FILTER ELEMENT

1. Remove:
• Rider seat
L LLL L L LLL L L LLL L
M MMM M M MMM M M MMM M
1
L LLL L L LLL L L LLL L
• Left side cover
Refer to "GENERAL CHASSIS" on page 37.
• Shift actuator
Refer to "SHIFT ACTUATOR AND SHIFT
ROD" on page 57.
• Air filter case cover
• Air filter element
Refer to "GENERAL CHASSIS" on page 37.
2. Clean:
• Air filter element
LLL
Apply compressed air to the outer surface of
the air filter element.
3. Check:
MMM
• Air filter element
Damage → Replace.
EC3P61043
CAUTION:
Never operate the engine without the air filter
element installed. Unfiltered air will cause
rapid wear of engine parts and may damage
the engine. Operating the engine without the
air filter element will also affect throttle body
synchronization, leading to poor engine per-
formance and possible overheating.
4. Install:
• Air filter element
• Air filter case cover
Refer to "GENERAL CHASSIS" on page 37.
• Shift actuator
Refer to "SHIFT ACTUATOR AND SHIFT
ROD" on page 57.
• Left side cover
• Rider seat
Refer to "GENERAL CHASSIS" on page 37.
NOTE:
When installing the air filter element into the air
filter case cover, make sure their sealing surfac-
es are aligned to prevent any air leaks.
LLL
– 34 –
ENGINE