Removal And Installation; Leaking Or Damaged Components Except A/C Compressor, Accumulator Or Receiver - Circuit Empty Of Refrigerant - Audi 100 1991 Repair Manual

Audi 100 1991 ➤ , Audi 80 1992 ➤ , Audi A1 2011 ➤ , Audi A2 2001 ➤ , A ...
5

Removal and Installation

⇒ "5.1 Leaking or Damaged Components Except A/C Compres‐
sor, Accumulator or Receiver - Circuit Empty of Refrigerant", page
191
⇒ "5.2 Leaking or Damaged Components Except A/C Compres‐
sor, Accumulator or Receiver - Circuit Contains Refrigerant",
page 193
⇒ "5.3 Compressor, Replacing Without Flushing Refrigerant Cir‐
cuit", page 193
⇒ "5.4 Compressor, Replacing Due to Leakage Or Internal Dam‐
age", page 194
⇒ "5.5 Receiver or Accumulator and Restrictor, Replacing After
Cleaning Refrigerant Circuit", page 195
⇒ "5.6 Receiver or Accumulator, Replacing Without Flushing Re‐
frigerant Circuit", page 196
⇒ "5.7 Dryer Cartridge and Dryer Bag, Replacing Without Flush‐
ing Refrigerant Circuit", page 197
5.1 Leaking or Damaged Components Ex‐
cept A/C Compressor, Accumulator or
Receiver - Circuit Empty of Refrigerant
The refrigerant circuit was completely empty (for example with
larger leak or cracked hose)
Note
In the event of only a minor leak with slow escape of refrigerant
♦
(for example at a small leakage point), the amount of refriger‐
ant oil lost and the amount of moisture penetrating is not
sufficient to influence operation of the air conditioner.
The operations marked * are only to be implemented in case
♦
of a major leak (for example following an accident).
– Remove malfunctioning component.
– Remove A/C compressor.*
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Refrigerant R134a Servicing - Edition 01.2011
5. Removal and Installation
191