Troubleshooting & Repair; Monthly Maintenance; Ordering Replacement Parts - Cumberland Stove Works MF3800 Operation And Maintenance Manual

Monthly Maintenance

• Remove side baffles using 3/8" wrench. Clean the heat
exchanger tubes and the lower ledge near the ash pan of
all fly ash.
• Vacuum exhaust manifold behind ash pan.
• Cumberland Stove Works recommends changing the air filter
every 30 days. T he air filter is found on the back of the unit. See
FiGUre 11. Replacement filters can be ordered through your
stove dealer. Clean air filter (730008); regularly replace if needed.
Seasonal cleaning
• Remove all fuel from the hopper, firebox, firepot and ash
pan. Run auger to clear any remaining fuel from the auger.
It is important to clear the stove of all fuel at the end of
the burning season, as corn and pellets can accumulate
moisture over the summer months. This causes the unit
to rust and/or the fuel to mold.
• Remove the combustion motor and clean impellers and
motor housing of any fly ash.
• Vacuum the stove cavity to clear it of any fly ash or debris.
• Remove the exhaust venting and use a brush to clear all
soot, ash and debris.
NOTE: vENT MaY NEED TO BE CLEaNED Bi-aNNuaLY OR
EvERY 2-TONS OF FuEL BuRNED, DEPENDiNg ON THE
QuaLiTY aND aMOuNT OF FuEL uSED.
• Inspect all rope gaskets around the front door and ash pan.
When the unit is cleaned out, empty the hopper, take the venting
apart and clean out the fly ash. Then rinse and let dry. Inspect the
draft blower and clean out all areas. Clean the glass, doors and
outer cabinet so that you are ready for the next heating season.
The use of an ash vacuum makes cleaning easier and faster.
Figure 11: Air filter placement.
page 20
FOLLOW aLL daiLY, WeekLY and MOntHLY Maintenance
recOMMendatiOnS FOr OptiMUM perFOrMance.
USe an apprOVed aSH VacUUM WHen cLeaninG aSHeS
FrOM YOUr StOVe.
trOUBLeSHOOtinG & repair
At Ardisam, we build quality and durability into the design of our
products; however, no amount of careful design by us, and care-
ful maintenance by you, can guarantee a repair-free life for your
stove. Most repairs will be minor and are easily fixed by following
the suggestions in the troubleshooting guide in this section.
The guide will help you pinpoint the causes of common prob-
lems and identify remedies.
For more complicated repairs, you may want to rely on your
retailer, an authorized service center, or Ardisam, Inc. A parts
catalog is included in this section.
We will always be glad to answer any questions you have, or
help you find suitable assistance. To order parts or inquire
about warranty, call or write us at the address found below,
under the section "Ordering Replacement Parts. "

OrderinG repLaceMent partS

Parts can be obtained from the store where the stove was
purchased or direct from the factory. To order from the factory
call, write or e-mail to:
1160 eighth avenue, cumberland, Wisconsin 54829
Please include the following information with your order:
1. Part numbers
2. Part description
3. Quantity
4. Model number and serial number
cumberlandStoveWorks.com
OPERATION AND Maintenance MANUAL
caUtiOn
iMpOrtant
ardisam, inc.
1-800-345-6007 • 1-715-822-2415
e-mail: info@ardisam.com
Model MF3800
800-345-6007