1. Manuals
  2. Brands
  3. Cumberland Stove Works Manuals
  4. Stove
  5. MF3800
  6. Operation and maintenance manual

Cumberland Stove Works MF3800 Operation And Maintenance Manual

Multi-fuel parlor stove
Hide thumbs Also See for MF3800:
Table of Contents

Advertisement

Quick Links

See also: Troubleshooting Manual , Installation and Servicing Manual
LEAVE ThIS
MAnUAL wITh
RESPOnSIbLE FOR ITS USE And OPERATIOn.
• Important operating and maintenance instructions included.
• Read, understand and follow these instructions for safe installation
and operation.
• This stove should not be used as the only source of heat in the
house. Power outages and periodic maintenance will result in
a total loss of heat.
HOt! dO nOt tOUcH. SeVere BUrnS MaY reSULt.
cLOtHinG iGnitiOn MaY reSULt.
Glass and other surfaces are hot during operation and
cool down.
• Keep children away.
• CAREFULLY SUPERVISE children in same room as appliance.
• Alert children and adults to hazards of high temperatures.
• DO NOT operate with protective barriers open or removed.
• Keep clothing, furniture, draperies and other combustibles
away.
Tested and approved for shelled field corn, approved pellets and
cherry pits. Burning any other type of fuel voids the warranty.
please read this entire manual before installation and
using this multi-fuel-burning room heater. Failure
to follow these instructions could result in property
damage, bodily injury or even death.
• Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
• Do not overfire - If any external part starts to glow, you
are overfiring. Reduce feed rate. Overfiring will void
the warranty.
• Comply with all minimum clearances to combustibles
as specified in the manual. Failure to comply may cause
a house fire.
check building codes prior to installation.
• Installation MUST comply with local, regional, state and
national codes and regulations.
• Consult local building or fire officials about restrictions and
installation inspection requirements in your area.
• Notify insurance company of parlor stove installation.
Patent no. 7,823,578
Any
PARTy
PRIOR TO
MUST
FOR
PROcEdURES, SEE ThE InSTALLATIOn
And SERVIcE MAnUAL ThAT cOMES
wITh ThE STOVE OR cOnTAcT A
cERTIFIEd dEALER.
bE
InSTALLATIOn dEALER.
WarninG
OPERATIOn, ThIS
bE
InSTALLEd
InSTALLATIOn
And
STOVES ShOULd
InSTALLEd
by
A
QUALIFIEd
OperatiOn and
Maintenance ManUaL
MF3800
MULTI-FUEL
PARLOR STOVE
UnIT
PROPERLy.
SERVIcE
Rev. Date 11/17/10
© 2010 Ardisam, Inc.
All Rights Reserved.
OMMF3800

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the MF3800 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Cumberland Stove Works MF3800

Summary of Contents for Cumberland Stove Works MF3800

  • Page 1 OperatiOn and Maintenance ManUaL MF3800 MULTI-FUEL PARLOR STOVE LEAVE ThIS MAnUAL wITh PARTy RESPOnSIbLE FOR ITS USE And OPERATIOn. • Important operating and maintenance instructions included. • Read, understand and follow these instructions for safe installation and operation. • This stove should not be used as the only source of heat in the house. Power outages and periodic maintenance will result in a total loss of heat.

  • Page 2: Table Of Contents

    OPERATIOn AND MAINTENANCE MANUAL Model MF3800 taBLe OF cOntentS WARRANTY................................................... 3 REgISTRATION, SERVICE & MAINTENANCE LOg ....................................4 WARNINgS & SAFETY PRECAUTIONS ........................................5-7 INTRODUCTION ................................................. 7 Burning Solid Fuels ................................................8 Shelled Corn..................................................8 Pellets ....................................................9 Automatic Safety Features ............................................9 MAjOR STOVE COMPONENTS ............................................10 SPECIFICATIONS ................................................11 INITIAL SET-UP ..................................................12 OPERATINg INSTRUCTIONS ..........................................13-16 Becoming Familiar with your Tri-X Controller Key Pad ..................................13 When you are Ready to Use your Stove .........................................13 Fuel Range Selection ..............................................13...

  • Page 3: Warranty

    The warranty applies only to products which have not been subjected to negligent use, misuse, alteration, accident or repairs made by anyone not certified by Cumberland Stove Works. This guarantee is void unless the warranty card is properly filled out and returned to Ardisam, Inc., Cumberland, WI, at the time of purchase.

  • Page 4: Registration, Service & Maintenance Log

    OPERATIOn AND MAINTENANCE MANUAL Model MF3800 reGiStratiOn, SerVice and Maintenance LOG Record the model number and serial number in the space provided for easy reference. Fill out and mail the registration card located in the parts packet or register online at www.cumberlandstoveworks.com. Warranty is valid only if the completed registration is received by Ardisam, Inc. within 30 days of purchase. OWnerSHip recOrdS Dealer’s Name: Dealer’s Address: City: State/Province: Zip Code/Postal Code: Model Number: Serial Number: Date of Purchase: Notes: SerVice date SerVice tecHnician SerVice deScriptiOn cumberlandStoveWorks.com page 4...

  • Page 5: Warnings And Safety Precautions

    OPERATIOn AND MAINTENANCE MANUAL Model MF3800 WarninGS and SaFetY precaUtiOnS • This stove is designed and • If you suspect a problem or approved for pelletized wood malfunction with the stove, do not fuel, cherry pits, or corn with no unplug it. Turn the MODE SWITCh more than 14% moisture. to “OFF” and periodically inspect the stove. • Do not operate the stove if the • This unit must be properly installed...
  • Page 6 OPERATIOn AND MAINTENANCE MANUAL Model MF3800 WarninGS and SaFetY precaUtiOnS • The exhaust system should be • Before cleaining or performing checked twice a year minimum any service to your stove, ensure for any build-up of soot or the stove has had time to cool.
  • Page 7 OPERATIOn AND MAINTENANCE MANUAL Model MF3800 WarninGS and SaFetY precaUtiOnS caUtiOn dO nOt burn garbage in this unit. The burning of other • solid fuels such as cord wood or wood chips in this stove is • Installation and repair of this parlor stove should be done by a qualified service person. The appliance not permitted. Burning any fuels in the stove that are not certified by Cumberland Stove Works will void the warranty. should be inspected before use and at least annually by a qualified service person. It is imperative that • dO nOt install a flue damper in the exhaust venting system control compartments, fire box, and circulating air of this unit.

  • Page 8: Introduction

    LeSS FreqUent cLeaninG. moisture. Test the moisture content periodically to ensure the proper dryness. caUtiOn • There are many varieties of corn. Each variety has unique characteristics including the shape and size of the kernel. cUMBerLand StOVe WOrkS dOeS nOt recOMMend As corn characteristics change, the fuel range may have to BUrninG tHe StOVe On tHerMOStat MOde, eitHer change accordingly. LOcaL Or reMOte, WHen BUrninG cOrn Or peLLet BLendS. Spent aSH MateriaL WiLL BUiLd Up in tHe pOt, inHiBit tHe iGnitOr FUnctiOn and caUSe a ViOLent iGnitiOn.

  • Page 9: Pellets

    OPERATIOn AND MAINTENANCE MANUAL Model MF3800 PELLETS caUtiOn • As with corn, find a consistent pellet supplier. Pellets will vary in content and burn characteristics from supplier to B U r n i n G W O O d p e L L e t S a c c O r d i n G t O recOMMendatiOnS WiLL enSUre LOnGer StOVe LiFe supplier. A consistent supply of pellets will result in a more...

  • Page 10: Major Stove Components

    OPERATIOn AND MAINTENANCE MANUAL Model MF3800 MAJOR STOVE cOMPOnEnTS Take a few moments to familiarize yourself with the major components of the Cumberland MF3800 Stove. Many of these items are referred to throughout the manual. FIREPOT HOLDER CONTROLLER HOPPER FIREPOT DOOR HEAT FIRE PLATE EXCHANGER DOOR HANDLE Notch POT ROD CONTROLLER MOUNT ASH PAN COMMUNICATION CABLE FOR CONTROL KEY PAD AIR FILTER COMMUNICATION CABLE PORT FOR CONTROL KEY PAD...

  • Page 11: Specifications

    BTU/hour input (1) 45,000 max WitH aStM e1509, (UM) 84-HUd, ULc/Ord-c-1482, and heating Capacity (2) 2,400 Sq. Ft. UcL S627-2000. Electrical Rating (3) 110 Volts, 15 Amp, 60 cUMBerLand StOVe WOrkS, ManUFactUrer OF tHiS appLiance, reSerVeS tHe riGHt tO aLter itS prOdUctS, tHeir SpeciFicatiOnS and/Or price WitHOUt nOtice. Power Consumption Controller = 2.0 Watts Stove = 200 Watts (800 Watts total while WarninG...

  • Page 12: Initial Setup

    OPERATIOn AND MAINTENANCE MANUAL Model MF3800 initiaL SetUp WarninG checking the Fuel Shutoff Gate neVer reSet FUeL Gate BY reacHinG tHrOUGH tHe air Once the stove has been properly installed and plugged into cLeaner OpeninG. tHiS WiLL daMaGe tHe caBLe and a grounded surge protector, you are nearly ready to begin Hinder Gate OperatiOn.

  • Page 13: Operating Instructions

    OPERATIOn AND MAINTENANCE MANUAL Model MF3800 OperatiOn WarninG BecOMinG FaMiLiar WitH YOUr neVer pUt StartinG peLLetS Or BUrn GeL intO tHe tri-x cOntrOLLer keY pad HOpper OF tHe StOVe. tHiS cOULd reSULt in deatH Or SeriOUS inJUrY and Or prOpertY daMaGe. dOinG SO WiLL VOid aLL WarrantieS.

  • Page 14: Electric Ignition Instructions

    OPERATIOn AND MAINTENANCE MANUAL Model MF3800 eLectric iGnitiOn inStrUctiOnS NOTE: Hot stoves need air circulating through them at all times to prevent overheating the electronic controls. After the range has been selected, the controller will then read: Therefore, once proof of fire is made, the convection fan will continue to run. Fan speed increases with level increase. at Level 6, it cannot be turned down.

  • Page 15: Thermostatic Control Operation

    LOcaL t-Stat – The local thermostat is the thermostat located inside the controller display. To use this mode press cUMBerLand StOVe WOrkS dOeS nOt recOMMend the thermostat button until the following screen is displayed: BUrninG tHe StOVe On tHerMOStat MOde, eitHer LOcaL Or reMOte, WHen BUrninG cOrn Or peLLet BLendS. Spent aSH MateriaL WiLL BUiLd Up in tHe pOt, inHiBit tHe iGnitOr FUnctiOn and caUSe a ViOLent iGnitiOn.

  • Page 16: Manually Starting A Fire

    OPERATIOn AND MAINTENANCE MANUAL Model MF3800 ManUaLLY StartinG a Fire For MF3800 models, as soon as the room temperature drops below the chosen heat setting, the stove will automatically go Once you have selected the feed range, if the stove fails to into electric ignite mode. electrically ignite, the MF3800 stove can be manually lit. NOTE: Due to the nature of solid fuels, some fuels will reignite iMPORTaNT: Before lighting the stove for the first time, make in thermostat mode better than others. For example, wood sure that no shipping items have been left inside the firebox pellets leave a fine dust such as ash that is easily blown out or ash pan.

  • Page 17: Explanation Of Fault Message Screens

    W H e n p e r F O r M i n G a nY i n t e r n a L e L e c t r i c a L cUMBerLand StOVe WOrkS dOeS nOt recOMMend...

  • Page 18: Normal Care & Maintenance

    OPERATION AND Maintenance MANUAL Model MF3800 nOrMaL care & Maintenance caUtiOn cleaning the Glass dO nOt Operate StOVe WitH BrOken GLaSS. Only clean glass when the glass is cool. Wipe the glass clean dO nOt SLaM tHe dOOr SHUt. with a dry or damp rag. If this does not clean the glass, use any dO nOt Strike GLaSS. non-abrasive cleaner. dO nOt USe aBraSiVe cLeanerS. removal of Broken ceramic Glass dO nOt cLean HOt GLaSS.

  • Page 19: Daily Maintenance

    OPERATION AND Maintenance MANUAL Model MF3800 daily Maintenance the surfaces on the stove may be hot. Always wear protective gloves even when the stove is cool to the touch. • Empty firepot of ashes. For this, you’ll need to unlock the firepot, dump the ashes, and relock the firepot. To unlock the firepot to dump the ashes into the ash pan, lift up on the pull rod and pull the rod back towards you.

  • Page 20: Troubleshooting & Repair

    OPERATION AND Maintenance MANUAL Model MF3800 Monthly Maintenance caUtiOn • Remove side baffles using 3/8” wrench. Clean the heat exchanger tubes and the lower ledge near the ash pan of FOLLOW aLL daiLY, WeekLY and MOntHLY Maintenance all fly ash. recOMMendatiOnS FOr OptiMUM perFOrMance. • Vacuum exhaust manifold behind ash pan. • Cumberland Stove Works recommends changing the air filter iMpOrtant every 30 days. T he air filter is found on the back of the unit. See FiGUre 11. Replacement filters can be ordered through your USe an apprOVed aSH VacUUM WHen cLeaninG aSHeS stove dealer. Clean air filter (730008); regularly replace if needed.

  • Page 21: Troubleshooting Guide

    OPERATION AND Maintenance MANUAL Model MF3800 trOUBLeSHOOtinG GUide WarninG Unplug stove before performing any maintenance. neVer SerVice Or tOUcH tHe Feed aUGer WitH tHe StOVe pLUGGed in. problem display Status possible causes remedy No power Check to see if stove is plugged in Check communication cable Check electrical outlet for power NO READINg Check fuse on incoming red power wire Defective control head Test and replace control head if needed Stove Will Not Feed Pellets hopper is empty Add fuel to hopper hopper lid is open Close hopper lid Pellet and/or auger jam Check auger for fines or pellet jam...
  • Page 22 OPERATION AND Maintenance MANUAL Model MF3800 problem display Status possible causes remedy hopper is empty Add fuel to hopper Plugged firepot Clean firepot. Clear all holes of ash or debris. Igniter slipped out of torque arm Push igniter back into place NORMAL READINg Stove Will Not Light Igniter failed Test igniter output leads on IM. Confirm air pump operation. Replace igniter if needed. No power to igniter Replace IM NO PROOF OF FIRE Igniter failed Test igniter output leads on IM. PUSh “ON” TO START Confirm air pump operation. Replace igniter if needed. Plugged firepot Clean firepot. Clear all holes of ash or debris. Pot Loading Pellets Poor quality fuel Change fuel supplier/moisture test corn NORMAL READINg Firepot misaligned Make sure firepot is aligned properly and that there is no unburned pellets obstructing proper alignment of firepot.

  • Page 23: Parts

    OPERATION AND Maintenance MANUAL Model MF3800 Main aSSeMBLY partS cumberlandStoveWorks.com 800-345-6007 page 23...
  • Page 24 OPERATION AND Maintenance MANUAL Model MF3800 Main aSSeMBLY partS keY # part # deScriptiOn qYt. keY # part # deScriptiOn qtY. 710042 BASE 710116 IgNITER PLUg (3700 ONLY) 710106 FIREBOX W/AIRWASh 710097 STOVE TOP 700076 POT CLEANINg ROD 710098 FIREPLATE 700250 RIghT UPRIghT 730067 OUTBOARD AUgER gASKET 700300 LEFT UPRIghT 720015 PROOF OF FIRE SWITCh 710008 FOOT...
  • Page 25 OPERATION AND Maintenance MANUAL Model MF3800 GLaSS dOOr partS (710095) aSH pan partS (710053) keY # part # deScriptiOn 700311 DOOR CASTINg keY # part # deScriptiOn 720002 gLASS 710099 ASh PAN 720075 WINDOW gASKET ROPE 730006 hANDLE, ASh DOOR (gOLD) 700200 gLASS CLIP 730044 hANDLE, ASh DOOR (SILVER) 725000 BOLT 10-24 X 3/8 TBhMS gR2 BLK ZN F-T 725012 BOLT 8-32 X 3/8 PPhMS gR2 ZN F-T 700398 gASKET MAIN DOOR...
  • Page 26 OPERATION AND Maintenance MANUAL Model MF3800 exHaUSt partS (710105) keY # part # deScriptiOn qtY. 710103 EXhAUST MANIFOLD 720060 MOTOR AND FAN 720059 COMBUSTION MOTOR gASKET 720015 SWITCh, SNAP DISC 700057 BOLT 1/4-20 X 3/4 SLhWh TF gR8 725014 SCREW #6-20 X 3/4 ShhSD ZN 725007 SCREW #10 X 3/8 SLhNNZN 720056 SQUARE TO ROUND TRANSITION CASTINg 720021 COMBUSTION BLOWER gASKET 720078 COMBUSTION MOTOR AND FAN ASSEMBLY (KEYS 2-9) *Key #s 2-9 are also a part of Key #10, the Combustion Motor and Fan Assembly. cumberlandStoveWorks.com page 26 800-345-6007...
  • Page 27 OPERATION AND Maintenance MANUAL Model MF3800 aUGer partS (710108) keY # part # deScriptiOn qtY. 710101 AUgER hOUSINg 700373 TORQUE ARM SLOTTED 730022 AUgER BUShINg 700025 INBOARD AUgER PLATE K1038 SET SCREW 720079 gEAR MOTOR 700033 AUgER COUPLINg COLLAR 700057 BOLT 1/4-20 X 3/4 SLhWh TF gR8 ZN 730015 gASKET INBOARD AUgER 710009 WELDMENT AUgER 63118 BOLT 1/4-20 X 1/2 hhCS gR5 700375 PLATE ADjUSTABLE IgNITER FORK 8932 NUT 1/4-20 hKPSBW ZN 720100 SWITCh SNAP DISC cumberlandStoveWorks.com...
  • Page 28 OPERATION AND Maintenance MANUAL Model MF3800 FUeL SHUt OFF CABLE SLEEVE MUST BE CRIMPED AFTER CABLE IS ROUTED THRU HOPPER HOLE keY # part # deScriptiOn qtY. 725029 SCREW #8-18 X 1/2 PPhSD ZN 700420 COVER PANEL 720084 SPRINg hIgh LIMIT SWITCh 700421 SLIDE FUEL ShUT OFF PANEL 700425 SLEEVE 700424 CABLE FUEL ShUT OFF PULL 67537 BOLT 10-24 X 1 PPh 700422 TRIggER FUEL ShUT OFF...

  • Page 29: Wiring Diagram

    OPERATION AND Maintenance MANUAL Model MF3800 WirinG diaGraM cumberlandStoveWorks.com 800-345-6007 page 29...
  • Page 30 OPERATION AND Maintenance MANUAL Model MF3800 nOteS _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ cumberlandStoveWorks.com page 30 800-345-6007...
  • Page 31 OPERATION AND Maintenance MANUAL Model MF3800 nOteS _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ _______________________________________________________________________________________________________ cumberlandStoveWorks.com 800-345-6007 page 31...
  • Page 32 Cumberland Stove Works™, Division of Ardisam, Inc. 1160 8th Avenue, PO Box 666 Cumberland, WI 54829 800-345-6007 | Fax 715-822-2223 E-mail: info@ardisam.com...

Table of Contents

Save PDF