Cumberland Stove Works MF3800 Operator's Manual
Multi fuel parlor stove
Hide thumbs
Also See for MF3800:
- Installation and service manual (44 pages) ,
- Operation and maintenance manual (32 pages) ,
- Troubleshooting manual (2 pages)
Table of Contents
Advertisement
• Important operating and
maintenance instructions
included.
Please read this entire manual before
installation and use of this pellet fuel-
burning room heater. Failure to follow
these instructions could result in property
damage, bodily injury or even death.
• Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance.
• Do not overfire - If any external part starts to glow,
you are overfiring. Reduce feed rate. Overfiring will
void the warranty.
• Comply with all minimum clearances to combustibles
as specified. Failure to comply may cause a house
fire.
Tested and approved for shelled field corn, approved pellets
and cherry pits. Burning of any other type of fuel voids the
warranty.
ARDISAM
.com
MULTI FUEL PARLOR STOVE
OPERATOR'S MANUAL
Installation and Operation
MF3700, MF3800
SAVE THESE INSTRUCTIONS
• Read, understand and
follow these instructions
for safe installation and
operation.
WARNING
CAUTION
CumberlandStoveWorks.com
CAUTION
• Leave this manual with
party responsible for use
and operation.
HOT! DO NOT TOUCH. SEVERE BURNS
MAY RESULT. CLOTHING IGNITION MAY
RESULT.
Glass and other surfaces are hot
during operation and cool down.
• Keep children away.
• CAREFULLY SUPERVISE children in same room as
appliance.
• Alert children and adults to hazards of high temperatures.
• DO NOT operate with protective barriers open or removed.
• Keep clothing, furniture, draperies and other combustibles
away.
Check building codes prior to installation.
• Installation MUST comply with local, regional, state and
national codes and regulations.
• Consult local building or fire officials about restrictions and
installation inspection requirements in your area.
WARNING
CAUTION
OMMF3700/3800
Rev. Date 06/09/08
© 2008 Ardisam, Inc.
All Rights Reserved. Printed in USA.
Advertisement
Table of Contents
Troubleshooting
Related Manuals for Cumberland Stove Works MF3800
Summary of Contents for Cumberland Stove Works MF3800
-
Page 1: Installation And Operation
MULTI FUEL PARLOR STOVE OPERATOR’S MANUAL Installation and Operation MF3700, MF3800 CumberlandStoveWorks.com CAUTION SAVE THESE INSTRUCTIONS • Important operating and • Read, understand and • Leave this manual with maintenance instructions follow these instructions party responsible for use included. for safe installation and and operation. -
Page 3: Table Of Contents
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models TABLE OF CONTENTS WARRANTY ......................................2 REgISTRATION, SERVICE & MAINTENANCE LOg .........................3 WARNINgS & CAUTIONS ..................................4 Automatic Safety Features ................................5 INTRODUCTION ....................................6 Burning Solid Fuels....................................6 SPECIFICATIONS ....................................8 UNPACKINg & ASSEMBLY ................................9 CONTROLLER OPTIONS .................................10 INSTALLATION ....................................11... -
Page 4: Warranty
The warranty applies only to products which have not been subjected to negligent use, misuse, alteration, accident or repairs made by anyone not certified by Cumberland Stove Works. This guarantee is void unless the warranty card is properly filled out and returned to Ardisam, Inc., Cumberland, WI, at the time of purchase. -
Page 5: Registration, Service & Maintenance Log
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models REGISTRATION, SERVICE AND MAINTENANCE LOG Record the model number and serial number in the space provided for easy reference. Fill out and mail the registration card located in the parts packet or register online at www.cumberlandstoveworks.com. Warranty is valid only if the completed registration is received by Ardisam, Inc. -
Page 6: Warnings & Cautions
DO NOT burn garbage in this unit. The burning of The Cumberland Stove Works parlor stove is other solid fuels such as cord wood or wood chips designed to burn dry shelled field corn, wood in this stove is not permitted. Any fuels not certified pellets, and cherry pits. -
Page 7: Automatic Safety Features
Fresh Air Kit. Figure 1: Overtemp Reset Button in Back Panel For use in the United States. Approved for installation in mobile homes. Cumberland Stove Works, manufacturer of this appliance, reserves the right to alter its products, specifications and/or price without notice. push to reset Figure 2: Overtemp Reset Button on auger housing CumberlandStoveWorks.com... -
Page 8: Introduction
Congratulations on your investment in quality. Thank you NEVER BURN SEED CORN IN THE STOVE. SEED CORN for purchasing a Cumberland Stove Works Multi Fuel Par- IS TREATED WITH CHEMICAL PESTICIDES THAT ARE lor Stove from Ardisam, Inc. We have worked to ensure... - Page 9 INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models PeLLetS CAUTION • As with corn, find a consistent pellet supplier. Pellets will vary in content and burn characteristics from supplier B U R N I N G W O O D P E L L E T S A C C O R D I N G T O RECOMMENDATIONS WILL ASSURE LONGER STOVE to supplier.
-
Page 10: Specifications
COMPLY WITH ASTM E509, (UM) 84-HUD, ULC/ORD- Heating Capacity (2) 1,200 Sq. Ft. C-48. Electrical Rating (3) 110 Volts, 15 Amp, CUMBERLAND STOVE WORkS, MANUFACTURER OF 60 Hz THIS APPLIANCE, RESERVES THE RIGHT TO ALTER ITS PRODUCTS, THEIR SPECIFICATIONS AND/OR PRICE Power Consumption Controller = 2.0 Watts WITHOUT NOTICE. -
Page 11: Unpacking & Assembly
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models UNPACkING AND ASSEMBLY Unpack all hardware located in the units hopper and ash pan. The following should be included: 4 - legs (710008) w/ levelers (725010) 4 - tie-down straps (700136) 1 - firepot cleaning rod (700076) 1 - cleaning rod spring (720053) 1 - hopper lid handle (730006) 1 - power cord (720045) 1 - scraper tool (700225) 1 - door (700311) with glass (720002) and handle (700351, 700359) 1 - controller (730053) 1 - steel mounting bracket (700349) 1 - pre-made parts bag (small) which includes: 4 - 1/4-20 x 2” tie-down bolts (725015) Figure 4: Leg Assembly 2 - 8-32 x 3/8” hopper lid handle bolts (725012) 12 - 5/16-18 x 3/4” leg bolts (1501) 4 - #8-18 controller bracket screws (725027) MOUNT LEGS note: Stove is heavy. -
Page 12: Controller Options
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models MOUNTING THE CONTROLLER The CSW MF Series Stove has three different controller mounting options: 1. Back of the stove with controller visible.You may mount the conrollter on either side of the rear of the stove (see figure 8) so it is visible during operation. To do so use the metal mounting bracket and the (4) self-tapping screws ((2) through the plastic bracket and (2) through the back panel of the stove). Attach through the pre-drilled holes. note: Self-tapping screws must penetrate hopper. -
Page 13: Installation
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models INSTALLATION WARNING It is recommended the stove be installed and serviced by READ THIS ENTIRE MANUAL BEFORE YOU INSTALL authorized professionals who are certified by the National AND USE THIS STOVE. FAILURE TO FOLLOW THE Fireplace Institute (NFI) as NFI Pellet Specialists. INSTRUCTIONS MAY RESULT IN PROPERTY DAMAGE, BODILY INJURY, OR EVEN DEATH. -
Page 14: Clearance To Combustibles
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models CLEARANCES TO COMBUSTIBLES note: these are minimum clearances to combustible walls established by the aStm testing lab. 3” 3” 4” 3” 4” 4” 3” 6” 6” 4” Figure 14 Figure 15 STRAIGHT INSTALLATION... -
Page 15: Venting
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models VENTING WARNING Consult vent manufacturer’s specifications and DO NOT CONNECT THIS UNIT TO A CHIMNEY FLUE recommendations for all venting installations. SERVING ANOTHER APPLIANCE. DO NOT INSTALL A FLUE DAMPER IN THE EXHAUST The following installation guidelines must be followed to VENTING SYSTEM OF THIS UNIT. -
Page 16: Vent Termination Clearances
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models INSTALLING REMOTE THERMOSTAT VENT TERMINATION CLEARANCES The MF Parlor Stove can be run thermostatically by CLEARANCE purchasing any milivolt thermostat (sold separately). This Clearance below or beside any door or window 4 feet step is optional and not required for MF Parlor Stove to that opens. -
Page 17: Outside Air Connection
9 - Scroll Allows user to change heat ranges. Allows user to browse heat ranges. 4. All vertical chimney vents must have wall supports. MF3800 users have the option of running the igniter during normal operation. 5. All exhaust systems must have a spark arrestor. 10 - Enter - Chooses the top selection of the screen... -
Page 18: Operating Stove
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models OPERATING STOVE WARNING Once the stove has been properly installed and plugged NEVER PUT STARTING PELLETS OR BURN GEL INTO into a grounded surge protector you are ready to begin THE HOPPER OF THE STOVE. THIS COULD RESULT operation. -
Page 19: Fuel Range Selection
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models lighter, close the door and press ON key. The sound During starting fire and electric ignition sequences you you hear after the ON key is pushed is the exhaust fan may change the level by pressing the TEMP UP or TEMP running. After the ON key is pressed the control will read DOWN buttons. -
Page 20: Thermostat Control Options
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models thermoStatiC ControL oPeration WARNING The stove has been designed to be run thermostatically two different ways. There is a built-in thermostat in the NEVER SHUT DOWN YOUR STOVE BY LEAVING THE HOPPER DOOR OPEN AND UNATTENDED. THIS COULD controller, or a remote thermostat can be installed (see CREATE AN UNSAFE CONDITION IF THE DWELLING IS INSTALLING REMOTE THERMOSTAT page 14). -
Page 21: Normal Care & Maintenance
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models NORMAL CARE & MAINTENANCE NO PROOF OF FIRE CLEANING THE GLASS PUSH ON TO START Only clean glass when the glass is cool. Wipe the glass clean with a dry or damp rag. If this does not clean the This means the stove went through the starting fire or glass use any non-abrasive liquid spray. - Page 22 INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models AIR FILTER CAUTION Replace air filter annually. Replacement filters can be DO NOT OPERATE STOVE WITH BROkEN GLASS. ordered through your stove dealer. DO NOT SLAM THE DOOR SHUT. DO NOT STRIkE GLASS.
-
Page 23: Monthly Maintenance
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models • Complete the daily maintenance by checking the seal WARNING on the doors. Look for pellets that may have been left behind during loading. Check that each of the door seals WHEN PERFORMING ANY INTERNAL ELECTRICAL are flush with the stove and sealing properly. -
Page 24: Troubleshooting & Repair
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models When the unit is cleaned out, empty the hopper, take the venting apart and clean out the fly ash, rinse and let dry. Inspect the draft blower and clean out all areas. Clean the glass, doors and outer cabinet so that you are ready for the next heating season. Use of an ash vacuum... -
Page 25: Troubleshooting Guide
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models WARNING TROUBLESHOOTING GUIDE Unplug stove before performing any maintenance. NEVER SERVICE OR TOUCH THE FEED AUGER WITH THE STOVE PLUGGED IN. PROBLEM CAUSE: Too rich air/fuel mixture ? Fire burns with a lazy, orange Make sure glass door is shut and Moisture content of fuel above 15%. -
Page 26: Parts
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models MAIN ASSEMBLY PARTS Figure 9 CumberlandStoveWorks.com Page 4 800-345-6007... - Page 27 INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models MAIN ASSEMBLY PARTS kEY # PART # DESCRIPTION kEY # PART # DESCRIPTION 710042 BASE 710116 IGNITER PLUG (3700 ONLY) 710106 FIREBOX W/AIRWASH 710097 STOVE TOP 700076 POT CLEANINg ROD 710098 FIREPLATE 700250 RIgHT UPRIgHT 730067 OUTBOARD AUgER gASKET...
- Page 28 INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models GLASS DOOR PARTS (70095) ASH PAN PARTS (70053) Figure 30 Figure 3 kEY # PART # DESCRIPTION 700311 CW ROTATINg HANDLE kEY # PART # DESCRIPTION 720002 gLASS 710099 ASH PAN 720075 WINDOW gASKET ROPE...
- Page 29 INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models EXHAUST PARTS (7005) Figure 3 kEY # PART # DESCRIPTION 710103 EXHAUST MANIFOLD 720005 BLOWER, COMBUSTION 720050 SWITCH, ROLLOUT LIMIT 720015 SWITCH, SNAP DISC 509 BOLT 1/4-20 X 1/2 SLHWH ZN F-T T/C 725014 SCREW 6-20 X 3/4 SHHSD ZN 725007 SCREW #10 X 3/8 SLHH ZN 720056 SQUARE TO ROUND TRANSITION CumberlandStoveWorks.com 800-345-6007...
- Page 30 INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models AUGER PARTS (7008) Figure 33 kEY # PART # DESCRIPTION 710101 AUgER HOUSINg 700243 TORQUE ARM 730022 AUgER BUSHINg 700025 INBOARD AUgER PLATE K1038 SET SCREW 720079 gEAR MOTOR 700033 AUgER COLLAR 509 BOLT...
-
Page 31: Wiring Diagram
INSTALLATION AND OPERATION MANUAL MF3700, MF3800 Models WIRING DIAGRAM Figure 34 CONVECTION HEAT TORCH BLOWER COMBUSTION AIR PUMP AUgER MOTOR BLOWER WHITE BLACK WHITE BLACK BLACK WHITE LINE IN WHITE BLACK LINE IN BLACK TO EXTERNAL THERMOSTAT WHITE TO EXTERNAL THERMOSTAT... - Page 32 ARDISAM .com Visit www.ardisam.com and discover more innovations that will benefit you throughout the year. Cumberland Stove Works, Division of Ardisam, Inc. 1360 First Avenue; P.O. Box 666 Cumberland, Wisconsin 54829 800-345-6007 · Fax (715) 822-2223 E-mail: info@ardisam.com...