Table of Contents
Advertisement
Quick Links
Installation and Operating In-
structions for Vented Gas Log
Sets- Hearth Kits
Models: SA18SHKSN, SA18SHKSP,
SA24SHKSN, SA24SHKSP,
SA30SHKSN, SA30SHKSP
Decorative Gas Appliance For Installation in Solid Fuel Burning Fireplaces
If the information in this manual is not followed exactly, a fire or explosion may result causing
property damage, personal injury or loss of life.
—
Do not store or use gasoline or other flam-
mable vapors and liquids in the vicinity of
this or any other appliance.
—
WHAT TO DO IF YOU SMELL GAS
•
Do not try to light any appliance.
•
Do not touch any electrical switch; do not
use any phone in your building.
•
Immediately call your gas supplier from a
neighbor's phone. Follow the gas
supplier's instructions.
•
If you cannot reach your gas supplier, call
the fire department.
Please record your gas log's model number for
future reference here:
Note: This model # can be found on the box or
the label attached to the back of the burner pan.
When used without fresh air, gas logs may give off carbon monoxide, an odorless, poisonous gas. Some
people such as pregnant women, people with heart or lung disease, and persons at high altitudes are
more affected by carbon monoxide than others.
Early signs of carbon monoxide poisoning resemble the flu: Headache, dizziness, and/or nausea. If you
have these signs, the gas logs may not be installed or working properly. Get fresh air at once! Have the
gas log set and chimney serviced before using it again.
Carbon Monoxide Poisoning May Lead to Death
CFM Specialty Home Products
410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777
www.majesticproducts.com • www.vermontcastings.com
Certified to ANSI Z21.60
and CGA 2.26 Standards
WARNING
Installation, service, and repair of this appli-
ance must be performed by a qualified
installer, service agency, company or gas
supplier experienced with this type of gas
appliance.
INSTALLER:
Read these instructions completely and care-
fully prior to beginning installation. After instal-
lation, leave these instructions with the owner.
OWNER:
Read these instructions and follow the warn-
ings. Save this manual for future reference.
Check local codes before installing this log set.
In some areas of the country, gas log sets are
restricted.
The installation and the provisions for combus-
tion and ventilation air must conform with the
National Fuel Gas Code, ANSI Z223.1/NFPA 54.
C E RT I F I E D
ATTENTION
3311882 12/04 Rev. 4
Advertisement
Table of Contents
Related Manuals for Vermont Castings SA18SHKSN
Summary of Contents for Vermont Castings SA18SHKSN
- Page 1 Installation and Operating In- structions for Vented Gas Log Sets- Hearth Kits Models: SA18SHKSN, SA18SHKSP, SA24SHKSN, SA24SHKSP, SA30SHKSN, SA30SHKSP C E RT I F I E D Certified to ANSI Z21.60 and CGA 2.26 Standards Decorative Gas Appliance For Installation in Solid Fuel Burning Fireplaces...
- Page 2 WARNING Improper installation, adjustment, alteration, service or maintenance can cause injury or property dam- age. Read these directions thoroughly before installation. For assistance or additional information, consult your gas log dealer, qualified installer, service agency or gas supplier. WARNING WARNING Do not use this appliance or any part that has Young children are not allowed to operate this unit and must be supervised when they are in the...
-
Page 3: Fireplace Specifications
Before You Begin -- Attention! A. The appliance should be inspected before use and at least annually by a professional service person. More frequent cleaning may be required due to excessive lint from carpeting, bedding material, etc. It is imperative that control compartments, burners and circulating air passageways of the appliance be kept clean. - Page 4 Pre-Installation Checklist Is the gas supply inlet pressure correct? NG: Min. 5.5” w.c./Max. 14.0” w.c. LP: Min. 11” w.c./Max. 14.0” w.c. Does the firebox meet the minimum size dimensions below? Is your fireplace plumbed with gas on the right side (facing) of the fireplace? If not, refer to ee Page 5.
-
Page 5: Tools Required
Tools Required 8” adjustable crescent wrench ; Pipe thread sealant compound or teflon tape ; 12” pipe wrench or channel lock pliers. Gas Plumbed On Left Hand Side Of Fireplace NOTE: Your gas log set is assembled at the factory to be installed in a fireplace plumbed with the gas on the right side (facing). - Page 6 Damper Stop Installation: For Use With All Other Fireplaces The Damper Clamp provided keeps your damper from accidentally closing during operation of your set. This Damper Clamp must be installed onto your Damper at all times. Install the Damper Clamp onto the edge of the damper plate.
-
Page 7: Connection To Gas Supply
Adding Pan Material 1. Open the bag of Vermiculite (for Propane Gas) Glowing Embers or Silica Sand (for Natural Gas) and spread it evenly across the Burner Pan, to the top, as shown in Figure 5. You may overflow the front and sides of the pan to cover the entire pan and connecting hardware. - Page 8 Log Placement Optional Fettel Cast Front Grate 1. Place the larger bottom logs onto the grate, Attach the fettel to the front of the grate as shown leaving as much space between them as in Figure 8. possible. When burning, the flames should come up directly between the logs.
- Page 9 18” Standard Split Log Set 18” Standard Combination Log Set LG336 LG333 24” Standard Split Log Set 24” Standard Combination Log Set LG337 30” Standard Combination Log Set LG334 30” Standard Split Log Set LG338 LG335 3311882...
-
Page 10: For Your Safety Read Before Lighting
For Your Safety Read Before Lighting WARNING: If you do not follow these directions exactly, a fire or explosion may result causing property damage, personal injury, or loss of life. What To Do If You Smell Gas • Do not try to light any appliance •... -
Page 11: Lighting The Pilot
Lighting The Pilot The pilot will resist lighting on new installa- PILOT tions due to air in the gas supply line. It may take several minutes to bleed air completely out of the gas plumbing system through the pilot line. This appliance has a pilot which is lit by a spark ignition device (piezo). - Page 12 Pilot Flame Adjustment The pilot flame should be steady and soft burning blue surrounding 1/2” inch of the thermocouple tip . If adjustment is necessary, the control has a pilot 1/2" adjustment screw located in the upper right of the control face.
- Page 13 Troubleshooting Burner Flame Is Too High (8”-12” Abover Top Logs) or Too Low: Incorrect gas supply, pressure, or burner orifice used: Make sure the gas pressure coming into the fireplace falls between the minimum pressures allowed with this gas set (refer to tables on Page 4) Blocked ports (low flame only): Free the main burner orifice and burner bar ports of any burrs, paint, or other blockage.
- Page 14 7a,b Optional Cast Fettel 16a,b,c CFM Specialty Home Products reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. SA18/24/30SHK Series Vented Gas Logs - Hearth Kit Ref. Description 18”...
- Page 15 SA18/24/30SHK Series Vented Gas Logs - Hearth Kit (continued) Ref. Description 18” 24” 30” Pilot Bracket 2000912 2000912 2000912 16a. Natural Gas Pilot Assembly (No Ignitor) 3304233 3304233 3304233 16b. Propane Gas Pilot Assembly (No Ignitor) 3304234 3304234 3304234 16c. Pilot &...
- Page 16 2g (2) 6e (2) 6f (2) 9e (2) CFM Specialty Home Products reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. SA18/24/30SHK Series Vented Gas Logs - Hearth Kit 3311882...
- Page 17 SA18/24/30SHK Series Vented Gas Logs - Hearth Kit (continued) Ref. Description Log Sets 18” Standard Split Log Set 20007857 18”/24”/30” Back Log 20007820 18”/24”/30” Cross Log 20007699 18” Split Right Front 20007823 18” Split Left Front 20007825 Top Log #3 (2 per set) 20008337 Top Log 20008336...
- Page 18 3311882...
- Page 19 FITNESS FOR A PARTICULAR PURPOSE), ALL OF specified in paragraphs A and B below with respect to its WHICH ARE HEREBY EXPRESSLY INCLUDED. IN NO Vermont Castings Decorative Gas Appliances (the “Gas EVENT SHALL ANY IMPLIED WARRANTY PRESCRIBED Appliance”), including CFM Specialty Home Products...
- Page 20 CFM Specialty Home Products 410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777 www.majesticproducts.com • www.vermontcastings.co...