Vermont Castings Jefferson JUVSR & JUVSM 3095, 3096, 3097, 3100, 3101, 3102, 3105, 3106, 3107, 3110, 3111, 3112 Installation And Operation Manual
Vermont castings vent free gas heater operation manual models: juvsr & juvsm 3095, 3096, 3097, 3100, 3101, 3102, 3105, 3106, 3107, 3110, 3111, 3112
Hide thumbs
Also See for Jefferson JUVSR & JUVSM 3095, 3096, 3097, 3100, 3101, 3102, 3105, 3106, 3107, 3110, 3111, 3112:
Table of Contents
Advertisement
Quick Links
INSTALLER / CONSUMER
SAFETY INFORMATION
Please read this manual before
installing and using appliance.
WARNING: If the information in this
manual is not followed exactly, a fire
or explosion may result causing
property damage, personal injury or
loss of life.
—Do not store or use gasoline or
other flammable vapors and
liquids in the vicinity of this or
any other appliance.
—WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appli-
ance.
• Do not touch any electrical
switch; do not use any phone
in your building.
• Immediately call your gas
suppler from a neighbor's
phone. Follow the gas
suppler's instructions.
• If you cannot reach your gas
supplier, call the fire depart-
ment.
Installation and service must be
performed by a qualified installer,
service agency or the gas supplier.
This is an unvented gas-fired heater.
It uses air (Oxygen) from the room
in which it is installed. Provisions for
adequate combustion and
ventilation air must be provided.
Refer to Page 7.
INSTALLER: DO NOT DISCARD THIS MANUAL - LEAVE FOR HOMEOWNER
Jefferson
Vent Free Gas Heater
Models: JUVSR & JUVSM
3095, 3096, 3097, 3100,
3101, 3102, 3105, 3106,
3107, 3110, 3111, 3112
Vermont Castings, Majestic Products
410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7885
www.majesticproducts.com • www.vermontcastings.com
®
Homeowner's Installation
and Operation Manual
20003447 6/03 Rev. 6
Advertisement
Table of Contents
Related Manuals for Vermont Castings Jefferson JUVSR & JUVSM 3095, 3096, 3097, 3100, 3101, 3102, 3105, 3106, 3107, 3110, 3111, 3112
Summary of Contents for Vermont Castings Jefferson JUVSR & JUVSM 3095, 3096, 3097, 3100, 3101, 3102, 3105, 3106, 3107, 3110, 3111, 3112
- Page 1 INSTALLER / CONSUMER SAFETY INFORMATION Please read this manual before installing and using appliance. WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. —Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or...
-
Page 2: Table Of Contents
Vermont Castings Jefferson Vent Free Gas Heater PLEASE READ THE INSTALLATION & OPERATING INSTRUCTIONS BEFORE USING APPLIANCE. Thank you and congratulations on your purchase of a Vermont Castings stove. IMPORTANT: Read all instructions and warnings carefully before starting installation. Failure to follow these instructions may result in a possible fire hazard and will void the warranty. -
Page 3: Installation And Operating Instructions
Installation & Operating Instructions In order to ensure safe and effective installation, this unit must be installed only by a qualified agency, individual, firm, corporation or company that is experienced in the installa- tion, repair and servicing of this type of appliance and is familiar with the building codes and installation techniques appropriate in your area. -
Page 4: Juvs Dimensions
Vermont Castings Jefferson Vent Free Gas Heater JUVS Dimensions 28 " (724mm) Valve Inlet 3" (76mm) 24" 14 " (610mm) (368mm) 8" (203mm) 3447 Fig. 1 Jefferson Vent Free dimensions. 20003447... -
Page 5: Clearance Requirements
Clearance Requirements Minimum Clearances to Combustible Materials Maintain clearance, (empty space), between combus- tible materials and the heater as specified below for the appropriate firebox shell being installed. A: Mantel Trim ... 12” (305mm) B: Side Wall/Trim ... 4” (102mm) C: Rear Wall ...4”... -
Page 6: Gas Specifications
Vermont Castings Jefferson Vent Free Gas Heater Gas Specifications Model Fuel Gas Control JUVSRN Nat. Millivolt JUVSRP Prop Millivolt JUVSMN Millivolt JUVSMP Prop Millivolt Firebox weight / shipping 110 lbs. Gas Inlet and Manifold Pressures Natural Inlet Minimum 5.5” w.c. Inlet Maximum 14”... -
Page 7: Vent Free Features
Vent Free Features The JUVS Gas Heater is an unvented gas appliance tested and listed to the ANSI standard Z21.11.2a.2001. The Vent Free Gas Heater is configured to use Natural Gas, (JUVSRN, JUVSMN ) or Propane (JUVSRP, JUVSMP). Because these heaters are clean-burning and highly energy-efficient, no venting system is required. - Page 8 Vermont Castings Jefferson Vent Free Gas Heater 2. Divide the volume of space by 50 cubic feet. The result is the maximum BTU/hour the space can support. Example: 3840 cubic feet divided by 50 = 76.8 or 76,800 BTU/hour. 3. Add the BTU/hour ratings of all fuel-burning appli- ances installed in the same space, including the following: Gas Water Heater...
-
Page 9: Assembly Procedures
Unpack the Stove Remove the stove assembly from the shipping carton and inspect it for loose or damaged parts. Do not install this appliance if any parts are loose or if there is any visual or suspected damage resulting from shipping or handling. -
Page 10: Install On/Off Switch
Vermont Castings Jefferson Vent Free Gas Heater 2. Disconnect the snapstat module from the leads inside the snapstat bracket. (Fig. 8) 3. Bend open the snapstat bracket. use your fingers or needle nose pliers to remove the black plastic grommet from the bracket. -
Page 11: Thermostat Connections
Thermostat Connection (optional) (R Models only) Use only a thermostat rated for 500 millivolts. Do not use low voltage (24V) thermostats. Check the table below for the appropriate gauge thermostat wire to use for the length of lead required in your installation. -
Page 12: Install Stove Front
Vermont Castings Jefferson Vent Free Gas Heater Lava Rock Fig. 15 Install lava rock and upper logs. Fig. 16 Completed log installation. The Front Plate attaches to the stove by four steel tabs that engage with corresponding cast ribs on the sides and bottom of the stove body. -
Page 13: Operation
Your First Fire Read these instructions carefully and familiarize yourself with the burner controls of this heater. The JUVSR uses a Honeywell control valve that allows thermostatic, on/off switch regulation and has a sepa- rate Piezo ignition button. (Fig. 20) The JUVSM is equipped with an SIT control valve for manual use only. -
Page 14: For Your Safety Read Before Lighting
Vermont Castings Jefferson Vent Free Gas Heater Lighting And Operating Instructions FOR YOUR SAFETY READ BEFORE LIGHTING WARNING:If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. -
Page 15: Troubleshooting
Follow these procedures in the order presented. CONDITION No spark at pilot when Ignitor is operated. The Ignitor Electrode sparks, but Pilot does not light. Pilot/Main Con- trol Fig. 24 JUVS Honeywell Control Valve Assembly. 20003447 Vermont Castings Jefferson Vent Free Gas Heater Troubleshooting W A R N I N G TURN OFF HEATER AND ALLOW TO COOL... - Page 16 Vermont Castings Jefferson Vent Free Gas Heater Troubleshooting cont’d. CONDITION Pilot lights but flame goes out when Control Knob is released. Fig. 26 Pilot flame is lifting. Thermopile Thermo- couple Fig. 27 Pilot flame is weak - does not touch Thermocouple. Fig.
-
Page 17: Maintenance
The following procedures will help ensure that your stove continues to perform safely and efficiently. Firebox Cleaning and Inspection Cleanliness is critical to correct operation of the heater. The log set, burner, valve controls and air circulation areas must all be kept free of dust and unobstructed by debris. -
Page 18: Replacement Parts
Vermont Castings Jefferson Vent Free Gas Heater Vermont Castings, Majestic Products reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. Jefferson Vent Free Gas Heater (JUVS) Models 3095, 3096, 3097, 3100, 3101, 3102, 3105, 3106, 3107, 3110, 3111, 3112 19a,b 16a,b... - Page 19 Jefferson Vent Free Gas Heater (JUVS) Models 3095, 3096, 3097, 3100, 3101, 3102, 3105, 3106, 3107, 3110, 3111, 3112 Ref. Description Gas Log Set - JUVS Log Rear JUVS Log Upper Left JUVS Log Upper Right JUVS Log Left JUVS Log Right JUVS Grille, JDV Screen, Grille JDV...
-
Page 20: Optional Accessories
Vermont Castings Jefferson Vent Free Gas Heater Fan Kits FK28 Fan Assembly The FK28 fan kit helps distribute heated air from within the firebox out into the room. The fan is controlled by a snapstat that turns power on and off as the firebox temperature rises above and falls below a preset temperature. -
Page 21: Limited Lifetime Warranty
PRODUCT COVERED BY THIS WARRANTY All Vermont Castings gas stoves, gas inserts, and gas fireplaces, and all Majestic or Northern Flame brand gas fireplaces equipped with an Insta-Flame Ceramic Burner, or standard steel tube burner. BASIC WARRANTY The Vermont Castings , Majestic Products Company (hereinafter referred to collectively as the Company) warrants that your new Vermont Castings or Majestic Gas Fireplace/Stove is free from manufacturing and material defects for a period of one year from the... - Page 22 Vermont Castings, Majestic Products 410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777 www.majesticproducts.com • www.vermontcastings.com © Vermont Castings, Majestic Products...
Need help?
Do you have a question about the Jefferson JUVSR & JUVSM 3095, 3096, 3097, 3100, 3101, 3102, 3105, 3106, 3107, 3110, 3111, 3112 and is the answer not in the manual?
Questions and answers