Related Manuals for Charmglow 730-0289
Summary of Contents for Charmglow 730-0289
- Page 1 Stainless Steel Gas Grill USE AND CARE GUIDE MODEL NO.: 730-0289 ® ® FOR OUTDOOR USE ONLY K15Y06N-1 PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE DO NOT RETURN TO PLACE OF PURCHASE...
-
Page 2: Table Of Contents
TABLE OF CONTENTS Safety Instructions …………………….. Operating Instructions………………….15 Cleaning & Maintenance………………16 Side shelf assembly………..…………. Trouble Shooting …………………….17~18 Side shelf handle assembly………..… Exploded View…………………………..19 Battery Assembly …………………….. Grill Parts List ……………………………20 Condiment assembly ……………. …… Grilling Hints …………………………….21 Installation of Nature gas regulator….. Grill Cooking Chart ………………………22~24 Grill Recipe Suggestions………………..25~27 To Match Light the Grill... -
Page 3: Safety Instructions
SAFETY INSTRUCTIONS ***** WARNING ***** FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open Lid. 4. If odor continues, immediately call your gas supplier or your fire department. K15Y06N-1... - Page 4 SAFETY INSTRUCTIONS WARNING Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual. DO NOT USE ALUMINUM FOIL TO LINE THE GRILL RACKS OR GRILL BOTTOM. This can severely upset combustion airflow or trap excessive heat in the control area. INSECT WARNING!!! Spiders and insects can nest in the burners of this and any other grill, and cause the gas to flow improperly.
- Page 5 SAFETY INSTRUCTIONS WARNING: Always keep your face and body as far away from the burner as possible when lighting. WARNING: IMPORTANT! BEFORE LIGHTING… Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use.
- Page 6 SAFETY INSTRUCTIONS CHILDREN SHOULD NOT BE LEFT ALONE OR TESTED IN ACCORDANCE WITH ANSI UNATTENDED IN AN AREA WHERE THE GRILL IS Z21.58a • CSA 1.6a-2006 STANDARD FOR BEING USED. NEVER ALLOW THEM TO SIT, STAND OUTDOOR COOKING GAS APPLIANCES. THIS OR PLAY ON OR AROUND THE GRILL AT ANY TIME.
- Page 7 GRILL. For proper lighting and performance of the burners keep the burner ports clean. It is necessary to The 730-0289 Charmglow Grill is designed for clean them periodically for optimum performance. optimum performance without the use of briquettes. The burners will only operate in one position and Do not place briquettes on the radiant as this will must be mounted correctly for safe operation.
-
Page 8: Safety Instructions
SAFETY INSTRUCTIONS CHECKING FOR GAS LEAKS 3. Apply the soap solution to all gas connections. Never test for leaks with a flame. Prior to first use Bubbles will appear in the soap solution if and at the beginning of each new season, you must connections are not properly sealed. -
Page 9: Side Shelf Assembly
SIDE SHELF ASSEMBLY 1. The screws used to attach the side shelf are already screwed into the left side burner And right side panel(see the figure below).loosen the screws from the left side burner And right side panel, install the side shelves and tighten screws as the figure shown below. -
Page 10: Side Shelf Handle Assembly
SIDE SHELF HANDLE ASSEMBLY The screws used to attach the side shelf handle are already screwed into the side shelf handle (see the figure below).loosen the screws from the side shelf handle, align with the holes in the side shelf, and secure into the holes on the right side shelf of the grill K15Y06N-1... -
Page 11: Battery Assembly
BATTERY ASSEMBLY 1. In order to install the battery, remove the ignition button housing. Please keep the positive pole of the battery facing toward you. Insert the battery into the housing. Replace the ignition button housing after battery is installed. CONDIMENT RACK ASSEMBLY Assemble the condiment rack inside of the left door. -
Page 12: Installation Of Nature Gas Regulator
INSTALLATION OF NATURE GAS REGULATOR 1. The Nature Gas regulator has been factory installed. Attach the PVC Gas Hose to the regulator (See drawing below). 2. Connect the other end of the PVC Gas Hose to the house gas line using the quick-connect fitting. -
Page 13: To Match Light The Grill
TO MATCH LIGHT THE GRILL If the burner will not light after several attempts then the burner can be match lit. 2.you’ve just attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. Keep your face and hands as far away from the grill as possible. Insert a lit extended match or lighter through the cooking grids to the burner. -
Page 14: Lighting Instructions
LIGHTING INSTRUCTION 1. Become familiar with safety guidelines in CAUTION: front of the manual. DO NOT SMOKE Do not move grill trolley while in operation. WHILE LIGHTING THE GRILL OR CHECKING GAS SUPPLY If the grill fails to operate properly: CONNECTIONS. - Page 15 OPERATING INSTRUCTIONS Burn-off: Before cooking on your gas grill for the first time, burn off the grill to get rid of any odors or foreign matter by igniting the burners, closing the lid, and operating at a “HI” setting for about five minutes.
-
Page 16: Lighting Illustrations
LIGHTING ILLUSTRATIONS Rotisserie & Searing burner lighting illustration Main & side burner lighting illustration Step to light the rotisserie burner: Step 1: Make sure the lid is open Push and turn the rotisserie knob to ”IGNITE/ON” position and hold for 3~4 seconds, then push electronic ignition button at the same time until burner is lit. -
Page 17: Cleaning & Maintenance
Grease will not be able to drip down into grease collector and a grease fire could occur. EXTERIOR: Your Charmglow grill is made of heavy stainless steel; it should provide you with years of trouble-free service K15Y06N-1... -
Page 18: Trouble Shooting
TROUBLE SHOOTING PROBLEM SOLUTION When I light the grill it does not flame --Make sure you have turn on the gas immediately . --Make sure it has spark while you are trying to ignite the burner. --Push in for approximately 5 second before to turn and ignite the grill. - Page 19 Rotisserie motor will not turn --Check the voltage at the outlet. --If an extension cord is required, ensure it is a 16 gauges, grounded cord. --Ensure the on/off switch is on. --Ensure the load does not exceed the 40 pounds operational capacity.
-
Page 20: Exploded View
EXPLODED VIEW K15Y06N-1... -
Page 21: Grill Parts List
MODEL 730-0289 PARTS LIST ’ ’ – – K15Y06N-1... -
Page 22: Grilling Hints
GRILLING HINTS The doneness of meat, whether rare, medium, or well done, is affected to a large degree by To get the juiciest meats, add seasoning or salt the thickness of the cut. Expert chefs say it is after the cooking is finished on each side and impossible to have a rare doneness with a thin turn the meat only once (juices are lost when cut of meat. -
Page 23: Grill Cooking Chart
GRILL COOKING CHART WEIGHT OR FLAME APPROXIMATE SPECIAL INSTRUCTIONS FOOD THICKNESS SIZE TIME AND TIPS VEGETABLES Slice. Dot with butter or margarine. Wrap in heavy-duty foil. Fresh Grill, turning occasionally. Beets Medium 12 to 20 minutes Carrots Grill, turning once. Brush occasionally Turnips with melted butter or margarine. - Page 24 Rib eye, WEIGHT OR FLAME APPROXIMATE SPECIAL INSTRUCTIONS FOOD THICKNESS SIZE TIME AND TIPS Tenderloin, Porterhouse, T-Bone, Sirloin Remove excess fat from edge. Slash remaining fat at 2-inch Rare 1 inch High 8 to 14 minutes intervals. Grill, turning once. 1-1/2 inch High 11 to 18 minutes...
- Page 25 Halved or Medium 40 to 60 minutes Quartered well- done Breasts well- done Medium 30 to 45 minutes WEIGHT OR FLAME APPROXIMATE SPECIAL INSTRUCTIONS FOOD THICKNESS SIZE TIME AND TIPS FISH AND SEAFOOD Grill, turning once. Brush withmelted butter, margarine or Steaks oil to keep moist.
-
Page 26: Grill Recipe Suggestions
GRILL RECIPE SUGGESTIONS pork chops. Mix well. Pour duty foil. In a bowl, combine BBQ SALMON over chops and marinate one remaining ingredients. Mix hour in a cool place. Turn the well. Brush 1-1/2 tsp. Butter 2 large salmon steaks BBQ grill on full. - Page 27 4 cups thinly sliced potatoes Pound flank steak to ¼ inch alternately thread meat, (4 medium-sized potatoes) thickness or flatten chicken pepper, banana and breasts. Mix oil, lime juice mushrooms. Preheat grill. Preheat grill. Combine and seasonings in a zip lock Brush the kabobs with oil.
- Page 28 on the spit running the rod on your spit. Slide four prong on the spit rod. Place on the the fleshier side of the bone. meat hook down the length of rod and test for balance. spit and tighten. At the Light rotis burner.
-
Page 29: Limited Warranty
LIMITED WARRANTY MODEL 730-0289 STAINLESS STEEL OUTDOOR GAS GRILL Nexgrill Industries, Inc. warrants to the original consumer purchaser of each Outdoor Gas Grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below. This warranty excludes grills used in rental or commercial applications.