Related Manuals for Charmglow 720
Summary of Contents for Charmglow 720
- Page 1 STAINLESS STEEL GAS GRILL USE AND CARE GUIDE MODEL NO.: 720-0234 ® ® FOR OUTDOOR USE ONLY PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE DO NOT RETURN TO PLACE OF PURCHASE.
-
Page 2: Table Of Contents
TABLE OF CONTENT SECTION ONE SECTION THREE Importance………………………….….. 1 Care and maintenance……………………..19 Precautions…………………………. . 2-3 Care and maintenance of the side burner….20 Placement of the grill……………….…. 3 Trouble shooting…………………………..20 SECTION TWO SECTION FOUR Screw description………………………4 Assembly Instructions……………… 5-12 Exploded View……………………………21 Propane tank assembly………………... -
Page 3: Importance
IMPORTANCE * * * WARNING * * * FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid 4. If odor continues, immediately call your gas supplier or your fire department. FOR YOUR SAFETY 1. -
Page 4: Precautions
PERSONAL INJURY Use a covered hand when opening the grill lid. Never lean over an open grill. When properly cared for, your 720-0234 (Charmglow) Grill will give safe, reliable service for many years. WHEN LIGHTING A BURNER, ALWAYS PAY However, extreme care must be used since the grill CLOSE ATTENTION TO WHAT YOU ARE DOING. -
Page 5: Placement Of The Grill
GRILL. correctly for safe operation. The 720-0234 (Charmglow) Grill is designed for Clean the grill with caution. Avoid steam burns; do not optimum performance without the use of briquettes. Do use a wet sponge or cloth to clean the grill while it is hot. -
Page 6: Screw Description
Screw description Speci f i cat i on Q uant i t y Descr i pt i on( SCALE 1: 1) I t em cr ossed r ound head scr ew 8pcs 1/ 4× 42m m cr ossed r ound head scr ew 1/ 4×... -
Page 7: Assembly Instructions
ASSEMBLY INSTRUCTIONS PLEASE READ THE INSTRUCTIONS CAREFULLY AND FOLLOW STEP BY STEP. Attention: Please lock the caster during the process of installation of the grill. TOOLS REQUIRED: Philips head screwdriver(not provide),monkey wrench(not provide) Step 1: Assemble two regular casters to the right side panel and caster with brakes on the left side panel as shown figure below.. Step 2: : Assemble bottom panel to side panels with four (4) pcs 1/4*42 mm screws as shown figure below... - Page 8 Step 3: Assemble the back panel to the two side panels. with two (2)pcs 1/4*12mm screws and four (4) pcs 5/32*12 as shown figure below. Step 4: Assemble the front cart flame and back cart flame to the front side and back side of the side panel with eight (8) screws .
- Page 9 Insert fix piece of door shaft into the square pipe at left and right side as shown figure Step 5: below, screw four(4)pcs 5/32*12 screws. Attention: Do not screw too tight. Assembly the door in the fix piece of door shaft from bottom as shown figure and tighten Step 6: the screws.
- Page 10 First assemble the door handle to the door with the eight (8) pcs 5/32*10 screws as shown figure Step 7: below, then put the condiment rack inside of the left door as shown figure below. : Remove the head unit of grill from carton. Insert the upper portion of the grill onto the cart from Step8 the top.
- Page 11 : Open the lid ,take out the cooking grid first, then screw tighten the four(4) pcs 1/4*12 screws into Step9 the left side and right side of firebox as shown figure below. : Assemble the side shelf with three(3) pcs 1/4*12 screws as shown figure below. Step 10...
- Page 12 : Assemble the panel of side burner with three(3) pcs 1/4*12 screws as shown figure below. Step 11 :.Assemble the side shelf and panel of side burner into the firebox with eight(8) pcs 1/4*12 screws. Step 12 Attention: the upper screws to the firebox should be screwed from inside to outside for side shelf and side burner, but the screws below them should be firmed from outside into inside.
- Page 13 Side burner valve assembly: Step 1: Insert valve assembly through side Step 2: Remove 4(four)screws & washer from the “U” panel. . brackets on the side burner. (Side panel, right) Valve Step 3: Insert valve stem assembly into burner Step 4: Insert valve stem assembly into control panel. venturi.
- Page 14 Step13. Put the warming rack, grease tray and small grease box as shown figure below.
-
Page 15: Propane Tank Assembly
PROPANE TANK ASSEMBLY 1．With hand attach propane gas tank to regulator inlet fitting by turning the regulator clockwise until tight as shown in figure below. 2. LP gas cylinder must be fitted with a listed overfill prevention device (OPD). CAUTION! DO NOT USE TOOLS TO ATTACH REGULATOR / HOSE ASSEMBLY TO PROPANE TANK Put the gas tank into the gas tank tray, then tighten the tank retention screw as the picture shown below. -
Page 16: Your Gas Grill Is Ready To Use
Your gas grill is ready to use... -
Page 17: Gas Hook Up
CONNECTION: Total gas consumption (per hour) of The 720-0234 Your 720-0234 (Charmglow) grill is equipped with gas (Charmglow) Grill with all burners on “HI”: supply orifices for use only with liquid propane gas. -
Page 18: Installer Final Checklist
DO NOT SMOKE WHILE LEAK TESTING. supply may make it necessary to adjust the burners. The flames of the burners should be visually checked. NEVER PERFORM LEAK TEST WITH AN OPEN FLAME. Flames should be blue and stable with no yellow tips, excessive noise or lifting. -
Page 19: Operating Instructions
Make sure all knobs are “OFF” then turn on the gas supply from the LP tank. Always keep your face and body as far from the grill as possible when lighting. Your Charmglow grill has an exclusive patented built-in ignition. The igniter is built in to the valve. To ignite each burner simply push and turn the control knobs to the HI setting, you will hear the valve click as it sends a spark to the pilot flame. -
Page 20: To Match Light The Grill
Check for proper burner flame characteristics. Each burner is adjusted prior to shipment; however, variations in the local gas supply may take minor adjustments necessary. Burner flames should be blue and stable with no yellow tips, excessive noise, or lifting. If any of these conditions exist call our customer service line. -
Page 21: Using The Side Burner
USING THE SIDE BURNER counterclockwise to the “HI” position. If the burner does WARNING: IMPORTANT! USING THE SIDE BURNER: not light, turn the control knob to “OFF”. If the smell of Inspect the gas supply hose prior to turning the gas gas is detected and the igniter is not functioning, “ON”. -
Page 22: Care And Maintenance Of The Side Burner
CARE & MAINTENANCE OF SIDE BURNER BURNER CLEANING: Clean the exterior of the burner with a wire brush. Clear any clogged burner ports with a straightened paper clip. Never enlarge the burner ports. Never use a wooden toothpick as it may break off the clog the port. STAINLESS STEEL: There are many different stainless steel cleaners available. -
Page 23: Exploded View
Exploded View for 720-0234... -
Page 24: Parts List
MODEL 720-0234 PARTS LIST Part(Description) Part(Description) Inlet plastic loop Handle assembly, Lid Left door Base of handle Right door Heat indicator Left fix piece of door shaft ,Top Name plate Right fix piece of door shaft, Top Circumrotate screw Left fix piece of door shaft, Bottom... -
Page 25: Grilling Hints
GRILLING HINTS The doneness of meat, whether rare, medium, or well done, is affected to a large degree by the thickness of the To get the juiciest meats, add seasoning or salt after the cut. Expert chefs say it is impossible to have a rare cooking is finished on each side and turn the meat only doneness with a thin cut of meat. -
Page 26: Grill Cooking Chart
GRILL COOKING CHART WEIGHT OR APPROXIMATE SPECIAL INSTRUCTIONS FOOD THICKNESS FLAME SIZE TIME AND TIPS VEGETABLES Slice. Dot with butter or margarine. Wrap in heavy-duty foil. Grill, turning occasionally. Fresh Beets Medium 12 to 20 minutes Carrots Grill, turning once. Brush occasionally Turnips with melted butter or margarine. - Page 27 WEIGHT OR APPROXIMATE SPECIAL INSTRUCTIONS FOOD THICKNESS FLAME SIZE TIME AND TIPS Tenderloin, Porterhouse, T-Bone, Sirloin Remove excess fat from edge. Slash remaining fat at 2-inch intervals. Rare 1 inch High 8 to 14 minutes Grill, turning once. 1-1/2 inch High 11 to 18 minutes Medium...
- Page 28 WEIGHT OR APPROXIMATE SPECIAL INSTRUCTIONS FOOD THICKNESS FLAME SIZE TIME AND TIPS FISH AND SEAFOOD Grill, turning once. Brush withmelted butter, margarine or oil Steaks to keep moist. Halibut 3/4 to 1 inch Medium to 8 to 15 minutes Salmon High Swordfish Whole...
-
Page 29: Grill Recipe Suggestions
GRILL RECIPE SUGGESTIONS butter and sprinkled with chopped BBQ SALMON parsley and a crisp lettuce salad. BARBECUED LONDON 2 large salmon steaks BROIL 2 tbs. Oil Note: Substitute catfish, halibut or Salt & pepper cod for salmon. 4 to 6 servings 2 oz. - Page 30 minutes longer or until potatoes Serve 4 chop eggplant finely. Add all the are tender. Let stand 5 minutes ½ lb. boneless sirloin or beef cut seasonings. Chill thoroughly and before serving. into 1” cubes serve on toast. ½ lb. boneless loin of lamb cut into VEGETABLE KABOBS 1”...
- Page 31 accordion pleated. Fasten the second meat hook into the rack. Turn your rotis burner on high. Rotis for 50 minutes or until done. PORK ROAST Apple cider vinegar basting sauce: 1 c. apple cider vinegar 6 oz. water ½ stick butter Salt, pepper, parsley and garlic seasoning 2 oz.
-
Page 32: Limited Warranty
LIMITED WARRANTY MODEL 720-0234 STAINLESS STEEL OUTDOOR GAS GRILL Nexgrill Industries Inc. warrants to the original consumer purchaser of each Outdoor Gas Grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below. This warranty excludes grills used in rental or commercial applications.