Troubleshooting; Engine Won't Start; Generator Won't Produce Power; Storage - BOLIY Pro3600Si Owner's Manual

ENGINE WON'T START

1. Fuel system, engine is not getting fuel.
• No fuel in tank... Supply fuel.
• Clogged fuel line... Clean fuel line.
• Foreign matter in fuel filter... Replace fuel filter.
• Clogged carburetor... Clean carburetor.
2. Engine oil light flashes
• Oil level is low... Add engine oil.
3. Electrical system
• Engine switch to "ON". Poor or no spark.
• Spark plug is dirty... Replace sparkplug.
• Faulty ignition system... Consult dealer.
4. Compression Insufficient
•Worn out piston and cylinder... Consult dealer.

GENERATOR WON'T PRODUCE POWER

Stop the engine, then restart. If A/C lights continue to flash consult your dealer.

STORAGE

Long term storage of your machine will require some preventive procedures to guard against
deterioration.

DRAIN THE FUEL

1. Remove the fuel tank cap. Drain the fuel tank into an approved gasoline container using a
commercially available hand siphon. Then, install the fuel tank cap.
WARNING
• Fuel is highly flammable and poisonous.
• Wipe up any spilled fuel immediately.
2.Drain fuel from the carburetor by loosening the drain screw on the carburetor float chamber.
3.Turn the fuel cock lever to "OFF". Start the engine and leave it run until it stops.
This will burn any remaining fuel in the carburetor.

ENGINE

1. Remove the spark plug, pour about one tablespoon of SAE 10W30 or 20W40 motor oil into
the spark plug hole and reinstall the spark plug. Turn over engine several times (with
ignition off) to coat the cylinder walls with oil.
2. Pull the recoil starter until you feel compression. The stop pulling. (This prevents the
cylinder and valves from rusting).
3. Clean exterior of the generator and apply a rust inhibitor.
4. Store the generator in a dry, well-ventilated place, with the cover placed over it.
5. The generator must remain in a vertical position when stored, carried or operated.
15

TROUBLESHOOTING