Table Of Contents - Quadra-Fire Santa Fe Pellet Insert SANTAFEI-B Owner's Manual

R
Section 1: Listing and Code Approvals
A. Appliance Certifications ......................4
B. Mobile Home Approved ......................4
C. Glass Specifications ............................4
D. Electrical Rating ..................................4
E. BTU & Efficiency Specifications ..........4
Section 2: Getting Started
A. Design, Installation & Location
Considerations ....................................5
B. Locating Your Appliance & Chimney ..6
C. Draft ....................................................6
D. Negative Pressure ..............................6
E. Fire Safety ..........................................7
F. Tools & Supplies Needed ...................7
G. Inspect Appliance, Components
and Pre-Check List .............................7
Section 3: Dimensions & Clearances
A. Appliance Dimensions ........................8
B. Clearances to Combustibles
As A Built-In, UL and ULC ..................9
C. Clearances to Combustibles,
Masonry & Zero Clearance .................10
D. Floor Protection ..................................10
E. Minimum Opening for Factory
Built Fireplace .....................................10
F. Removing Floor of Factory Built
Fireplace .............................................11
Section 4: Vent Information
Chimney & Exhaust Connections
A.
B. Venting Termination Requirements ....12
C. Equivalent Feet of Pipe.......................13
D. Pipe Selection Chart ...........................13
Section 5: Venting Systems
A. Direct Connect with Outside Air ..........14
B. Direct Connect without Outside Air .....14
C. Full Reline with Outside Air .................15
Section 6: Mobile Home
Section 7: Appliance Set-Up
A. Leveling System .................................17
B. Outside Air Kit .....................................17
C. Grille Installation .................................18
D. Door Handle Installation .....................19
E. Door Trim Installation ..........................19
F. Door Removal .....................................19
G. Adjustable Hearth Support ..................20
H. Panel & Trim .......................................21
I. Log Set Placement ..............................22
J. Thermostat Installation ........................23
September 1, 2008

TABLE OF CONTENTS

........12
..................................16
Section 8: Operating Instructions
A. Fuel Size & Material ............................24
B. General Operation Information ...........24
C. Before Your First Fire .........................25
D. Starting Your First Fire ........................25
E. Fire Characteristics .............................25
F. Feed Rate Adjustment .......................25
G. Ignition Cycles ....................................26
H. Frequently Asked Questions...............26
Section 9: Troubleshooting
Section 10 Maintaining & Servicing Appliance
:
A. Proper Shutdown Procedures .............30
B. Quick Reference Maintenance Chart ..30
C. General Maintenance & Cleaning .......30-33
D. High Ash Content Maintenance ..........34
E. Blower Replacement ...........................35
F. Igniter Replacement ............................36
G. Glass Replacement .............................36
H. Baffle & Brick Removal .......................37-38
Section 12: Reference Material
A. Component Functions.........................39-40
B. Component Locations .........................41
C. Exploded Drawings .............................42-43
D. Service Parts & Accessories ...............44-46
E. Service & Maintenance Log ................47-48
F. Homeowner's Notes ............................49
G. Warranty Policy ...................................50-51
H. Contact Information .............................52
7019-205C
Santa Fe Pellet Insert
............................27-29
Page 3