Daily Inspection - TOHATSU MFS 3.5B Owner's Manual

1. Daily Inspection

Perform the following checks before
and after use.
Item
Fuel System
Engine oil
Electrical
Equipment
Throttle System
Recoil Starter
Clutch and
Visually check the propeller and shear pin for bent or
Propeller System
damaged blades.
Installation of
Motor
Cooling Water
Tools and Spares
Other parts
Points to Check
Check the amount of fuel in the tank.
Check for debris in the fuel filters.
Check the rubber hoses for fuel leakage.
Check the oil level, dirt and entering water.
Check that the stop switch functions normally and make
sure the lock plate is in right location
Check cords for loose connections and damage.
Check the spark plug for dirt,wear and carbon build-up.
Check that the carburetor choke valve functions normally.
Check carburetor linkage is warking normally when
turning the throttle grip.
Check the rope for wear and chafing.
Check the ratchet engagement.
Check that the clutch engages correctly when operation
the shift lever.
Check that the split pin is on the propeller.
Check the clamp screws attaching the motor to the boat
for tightness.
Check the thrust rod installation.
Check that cooling water is discharged from the cooling
water check port after the engine has started.
Check that there are tools and spare parts for replacing
spark plugs, the propeller, etc.
Check that you have the spare rope.
Check if the anode is securely installed.
Check the anode for corrosion and deformation.
INSPECTION AND MAINTENANCE
�������
!
Do not use outboard motor if any
abnormality is found during pre-operation
check or it could result in severe damage
to the motor or severe personal injury.
Fill fuel
Clean or Replace
Replace
Fill fuel or Replace
Remedy or replace
Correct or replace
Clean or replace
Replace
Correct
Replace
Correct or replace
Adjust
Replace
Tighten
Repair if necessary
Replace
33
1
2
3
Remedy
4
5
6
7
8
9
10
11
12
13