Run-In - Cushman HAULER 800X Owner's Manual

Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
down an incline. A sudden stop or change of direction may result in loss of control.
Slow down before and during turns. All turns should be made at reduced speed.
Never drive vehicle up, down, or across an incline that exceeds 14° (25% grade).
To reduce the possibility of severe injury or death resulting from improper vehicle operation, the
following warnings must be observed:
Refer to GENERAL SPECIFICATIONS for seating capacity.
Depressing accelerator pedal will release foot operated park brake and may cause inadvertent
vehicle movement. Turn the key to the 'OFF' position whenever the vehicle is parked.
To prevent inadvertent movement when the vehicle is to be left unattended, engage the park
brake, move direction selector to forward position, turn key to 'OFF' position and remove key.
Make sure that the direction selector is in correct position before attempting to start the vehicle.
Always bring the vehicle to a complete stop before shifting the direction selector.
Do not take vehicle out of 'gear' while in motion (coast).
Check the area behind the vehicle before operating in reverse.
All occupants must be seated. Keep entire body inside vehicle and hold on while vehicle is in
motion.

Run-in

Check for oil or fuel leaks that could have developed in shipment from the factory. Avoid full throttle starts and rapid
acceleration until the engine has achieved operating temperature.
All engines consume more oil than normal during the first hours of operation. As internal moving parts are run-in, oil
consumption should gradually decrease until the rate of consumption stabilizes.
Check the oil level per the Periodic Service Schedule. Add oil if the level on the dipstick indicates that oil is in the add
oil range.
Fill Cold Engine
To This Point
Add Oil
OPERATING PROCEDURES
Safe
Operating Range
Hot Engine
Check Oil Level on DipStick
Maximum Oil Level
For Hot Engine
Do Not Overfill
4 4 4 4
4 - 5