Volvo S80 Owner's Manual page 154

A. Battery without cover
B. Battery with cover
Removing the battery:
· Switch off the ignition and remove the key.
· Wait at least 5 minutes before touching any
electrical terminals. This allows time for the
information in the car's electrical system to
be stored in the control modules.
· Undo the screws from the lock brace over
the battery and remove the brace.
· Bend up the plastic cover over the negative
battery terminal or unscrew the cover from
the battery.
· Disconnect the negative battery cable.
· Detach the lower console holding the
battery.
· Bend aside the plastic cover and disconnect
3100181m
the positive cable.
· Remove the battery.
Fitting the battery:
·
Position the lower console and screw it in
place.
· Position the lower console and screw it in
place.
· Connect the positive cable, press in and fold
· Connect the negative cable, fold down the
plastic cover.
· Fit the plastic cover or the cover over the
battery.
· Make sure the evacuation hose is correctly
connected to both the battery and the outlet
in the bodywork.
· Fit the lock brace over the battery and
tighten the screws.
Batteries can generate oxyhydrogen gas,
which is very dangerous. One spark,
which can be generated if you connect
the jump leads incorrectly, is sufficient to
make the battery explode. The battery
contains sulphuric acid, which can cause
serious burns. If the acid comes into
contact with eyes, skin or clothing, flush
with large quantities of water. If acid
splashes into the eyes, seek medical
attention immediately.
153