Table of Contents
Advertisement
Models:
SP18NG, SP18LP, SP24NG,
SP24LP, SP30NG, SP30LP,
STSP18NG, STSP18LP,
STSP24NG, STSP24LP
Fireside Burner/Hearth Kits
Check with your local building code agency before you begin installation to ensure compliance with local codes, including
the need for permits and follow-up inspections. If you encounter any problems regarding code approvals, or if you need
clarification of any of the instructions contained here, contact the Technical Services Dept., Hearth & Home Technologies
Inc., phone 1-888-427-3973 or 1-800-927-6841.
•
Important operating
a n d m a i n t e n a n c e
instructions included.
WARNING
If the information in these instruc-
tions is not followed exactly, a
fire may result causing property
damage, personal injury, or death.
• Do not store or use gasoline or other flam-
mable vapors and liquids in the vicinity of
this or any other appliance.
• What to do if you smell gas:
- Do not try to light any appliance.
- Do not touch any electrical switch. Do not
use any phone in your building.
- Immediately call your gas supplier from
a neighbor's phone. Follow the gas
supplier's instructions.
- If you cannot reach your gas supplier, call
the fire department.
• Installation and service must be performed
by a qualified installer, service agency, or
the gas supplier.
Note: An arrow () found in the text signifies change in
content.
Hearth & Home Technologies • Fireside Burner/Hearth Kits • 4004-318 •Rev E 2/2013
CAUTION
DO NOT DISCARD THIS MANUAL
Read, understand
•
and follow these
instructions for safe
i n s t a l l a t i o n a n d
operation.
•
•
•
•
In the Commonwealth of Massachusetts:
•
•
•
Installation and service of this
appliance should be performed by
qualified personnel. Hearth & Home
Technologies suggests NFI certified
or factory-trained professionals, or
technicians super-
vised by an NFI
certified profes-
sional.
Leave this manual with
•
party responsible for
use and operation.
WARNING
HOT! DO NOT TOUCH.
SEVERE BURNS MAY RESULT.
CLOTHING IGNITION MAY RESULT.
Glass and other surfaces are hot during
operation and cool down.
Keep children away.
CAREFULLY SUPERVISE children in same room as
appliance.
Alert children and adults to hazards of high
temperatures.
Keep clothing, furniture, draperies and other
combustibles away.
This appliance must be installed by a licensed plumber
or gas fitter.
The chimney flue damper, when used with gas logs, will
be welded open or completely removed.
A CO detector shall be installed in the room where the
appliance is installed.
Installation
Instructions
Advertisement
Table of Contents
Related Manuals for Hearth and Home Technologies SP18NG, SP18LP, SP24NG
Summary of Contents for Hearth and Home Technologies SP18NG, SP18LP, SP24NG
- Page 1 Installation Instructions Installation and service of this Models: appliance should be performed by qualified personnel. Hearth & Home SP18NG, SP18LP, SP24NG, Technologies suggests NFI certified SP24LP, SP30NG, SP30LP, or factory-trained professionals, or STSP18NG, STSP18LP, technicians super- vised by an NFI...
- Page 2 Read this manual before installing or operating this appliance. Please retain this owner’s manual for future reference. Congratulations Congratulations on selecting a Fireside gas log set—an el- This owner’s manual should be retained for future reference. egant and clean alternative to burning wood. The Hearth & We suggest you keep it with your other important documents Home Technologies gas log set you have selected is de- and product manuals.
-
Page 3: Table Of Contents
Table of Contents Listing and Code Approvals A. Appliance Certification ......4 B. Table 1 ........4 Getting Started A. -
Page 4: Listing And Code Approvals
Listing and Code Approvals A. Appliance Certification WARNING The Fireside Burner/Hearth Kits have been tested and listed in the U.S. in accordance with ANSI Z21.60b-2004 (Gas Log Improper installation, adjustment, alteration, service Set). In Canada the Gas Log Hearth Kits have been tested or maintenance can cause injury or property damage. -
Page 5: Getting Started
WARNING Getting Started Hearth & Home Technologies disclaims any A. Size of Firebox responsibility for, and the warranty will be voided by, the following actions: See Table 1 in Section 1.B. • Installation and use of any damaged appliance or B. -
Page 6: Appliance Preparation
Note: A listed (and Commonwealth of Massachusetts WARNING approved) 1/2 in. (13 mm) T-handle manual shut-off valve and flexible gas connector are connected to the 1/2 in. Shock Risk (13 mm) control valve inlet. Fire Risk • If substituting for these components, please consult Use ONLY optional accessories approved local codes for compliance. -
Page 7: Gas Pressure
• Gas Supply Pressure: Minimum inlet gas supply pressure WARNING must be 4.5 in. W.C. for natural gas or 11 in. W.C. for LP gas for the purpose of input adjustment. Maximum inlet Fire Risk gas pressure must not exceed 7.0 in. W.C. for natural Explosion Risk gas or 13 in. -
Page 8: Installation Instructions
Installation Instructions Figure 4.2 Center Grate Over Burner Pan A. Install the Damper Stop • Open the damper to the fully open position and secure it open with the stop as shown in Figure 4.1. • If the damper stop doesn’t fit your application, use a permanent means that will keep the damper open at least to the minimum vent opening as outlined in Table 1, Section 1.B. -
Page 9: Install The Logs
E. Install the Logs G. Inspect the Venting System The fireplace venting system is designed and constructed to • Install the logs using the installation instructions included develop a positive flow adequate to remove flue gases to the with them. outside atmosphere. -
Page 10: Operating Instructions
Operating Instructions A. Lighting Instructions FOR YOUR SAFETY, READ BEFORE LIGHTING WARNING: IF THESE INSTRUCTIONS ARE NOT FOLLOWED EXACTLY, A FIRE OR EXPLO- SION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. A. This appliance has a pilot that must be lighted by hand. When lighting the pilot, follow these instructions exactly. -
Page 11: Glass Doors
B. Glass Doors • A qualified service technician must perform installation and repair. The appliance should be inspected and cleaned If your fireplace is equipped with glass doors: annually by a qualified service technician. More frequent • Glass doors should be in fully open position when cleaning may be required due to excessive lint, dust, pet appliance is operating. -
Page 12: Maintaining And Servicing The Appliance
Maintaining and Servicing the Appliance A. Servicing Your Appliance C. Annual Inspection WARNING WARNING Risk of injury or property damage Annual inspection by qualified technician recommended. Before servicing: Check: • Turn off gas. • Condition of doors, surrounds and fronts. •... -
Page 13: Troubleshooting
D. Troubleshooting With proper installation and maintenance, your new decorative gas appliance should provide years of trouble-free service. If you do experience a problem, refer to the troubleshooting guide below. This guide will assist you or a qualified service technician in the diagnosis of problems and the corrective action to be taken. Symptoms Possible Causes Corrective Action... -
Page 14: Reference Materials
Reference Materials A. Replacement Parts FIRESIDE HEaRtH KItS Service Parts Exploded Parts Diagram Beginning Manufacturing Date:8/1/2010 Ending Manufacturing Date: Active 1 - Burner Pan Assembly 18 in., 24 in., 30 in. 2 - Grate Assembly 18 in., 24 in., 30 in. Hearth Kit Assemblies-NATURAL Hearth Kit Assemblies- LP Hearth &... -
Page 15: Service Parts
FIRESIDE HEaRtH KItS Service Parts Beginning Manufacturing Date: 8/1/2010 Ending Manufacturing Date: Active Service Parts List Description of Part 18NG/LP 24NG/LP 30NG/LP Qty. Burner Pan Assembly SRVAGLBP14 SRVAGLBP18 SRVAGLBP24 Grate Assembly SRVAG16 SRVAG20 SRVAG24 Valve - SRVAF1000 SRVAF1000 SRVAF1000 * LP-Pilot Assy SRVE61L503B1 SRVE61L503B1 SRVE61L503B1... - Page 16 FIRESIDE HEaRtH KItS Service Parts Exploded Parts Diagram Beginning Manufacturing Date:8/1/2010 Ending Manufacturing Date: Active 1 - Burner Pan Assembly 2 - Grate Assembly 18 in., 24 in., 30 in. 18 in., 24 in., 30 in. Valve Assemblies See Thru Hearth Kit Assemblies- NG See Thru Hearth Kit Assemblies- LP Hearth &...
- Page 17 FIRESIDE HEaRtH KItS Service Parts Service Parts List Beginning Manufacturing Date: 8/1/2010 Ending Manufacturing Date: Active Description of Part STSP18NG STSP24NG STSP18LP STSP24LP Qty. Burner Pan Assembly SRVOBP-14ST SRVOBP-18ST SRVOBP-14ST SRVOBP-18ST Grate Assembly SRVSTG20 SRVSTG20 SRVSTG20 SRVSTG20 Valve - SRVAF1000 SRVAF1000 SRVAF1000 SRVAF1000...
-
Page 18: Optional Components
B. Optional Components Available for All Models REM-KIT Conversion Kit- From manual to variable flame with optional remote control LSK100-KIT Conversion Kit- From manual to on/off with a log switch LMK-SP Conversion kit - For left side piping Hearth & Home Technologies • Fireside Burner/Hearth Kits • 4004-318 • Rev E 2/2013... -
Page 19: Warranty
Hearth & Home Technologies • Fireside Burner/Hearth Kits • 4004-318•Rev E 2/2013... - Page 20 Hearth & Home Technologies • Fireside Burner/Hearth Kits • 4004-318 • Rev E 2/2013...
-
Page 21: Contact Information
D. Contact Information Please contact your Hearth & Home Technologies dealer with any questions or concerns. For the number of your nearest Hearth & Home Technologies dealer, please call 1-800-927-6841 or 1-888-427-3973. - NOTES - CAUTION DO NOT DISCARD THIS MANUAL Read, understand Leave this manual with •...