Troubleshooting Guide - X-TREME X-300 Owner's Manual

MAINTENANCE SCHEDULE
Proper care of your scooter will insure optimal performance and longer life span. The
following are a few maintenance suggestions that will keep your scooter running in top
condition:
Daily Maintenance
Perform each time you ride your scooter

Clean the exterior of the unit with a soft, damp rag. (DO NOT WASH WITH
A HOSE)

Check that all nuts and bolts are securely tightened.

Lubricate the chain with any silicone spray, 3&1 oil or any good clean motor
oil.

Check battery charger for any frayed/cut wires.
SYMPTONS
The charger light turns
green & red right away
Batteries do not hold a
charge. Unit does not
have specified travel range.
Unit moves intermittently or
very slow.
Unit will not move when
throttle lever is activated.
Unit stops abruptly during
use.

TROUBLESHOOTING GUIDE

POTENTIAL CAUSE
1. This indicates the
batteries are
adequately charged.
1. Batteries have
reached the end of
their useful life.
2. Charger is
malfunctioning.
1. Batteries not fully
charged.
2. Loose Wire.
3. Bad Throttle or
controller.
1. Batteries not fully
charged.
2. Brake switches out
of adjustment
3. Batteries have
reached the end of
their useful life.
Loose or broken wire.
Page12
SOLUTION
1. Continue to charge
the batteries for 6-8
hours prior to initial
use.
2. Look for loose or
disconnected wire
1. Replace Batteries
2. Replace Charger
Unit.
1. Charge or replace
batteries.
2. Check for loose
wires
3. Replace
1. Replace batteries or
charger.
2. Loosen brakes
3. Replace batteries.
1. Check for loose or
broken wires and
Repair/replace.