Hayward Salt & Swim® 3C Owner's Manual page 6

With power removed to the pump and water drained from the pool plumbing, secure the Cutting
Template to the location where the Cell Vessel will be installed. Note that the Cutting Template is the
same width as the Cell Vessel. The entire Cutting Template must fit on the pipe otherwise the Cell
Vessel will not fit. With the Cutting Template secure on the pipe, mark all 10 cutouts on to the pipe
using a waterproof permanent marker.
FILTER
PUMP
FROM
POOL
Remove the Template, cut the pipe and install the Nut Assemblies as shown below. Use the included
2" Nut Assembly for 2" pipe and 1½" Nut Assembly for 1½" pipe. Place Nut Assembly on each side
of the cut pipe (threads face in). Be sure to place the Nut, Compression Ring and Collar on the pipe
as shown in the diagram.
4
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
CUTTING TEMPLATE
Securely hold or tape this Cutting Template to the desired
Cell Vessel installation location. Use a waterproof permanent
marker to mark the pipe. When finished, there should be 12 marks
on the pipe. Follow procedures on the Installation Quick Start Guide
to complete Vessel installation.
1
Mark Pipe
2
Cut Pipe and
Clean Shavings
3
Slide Nuts
4
Slide Compression
Rings on pipe
5
Slide Collars
CUTT ING TE M P LATE
1 . S e c u r e l y h o l d t h i s C u t t i n g T e m p l a t e t o t h e d e s i r e d p i p e . T h e e n t i r e l e n g t h o f t h e G u i d e
o n t o t h e p i p e . 2 . W m u s t f i t i n t h e l o c a t i o n w h e r e t h e c e l l v e s s e l w i l l b e i n s t a l l e d . i t h a w a t e r p r o o f p e r m a n e n t m a r k e r , m a r k t h e c u t , c o m p r e s s i o n r i n g , a n d i n d i c a t o r m a r k c u t o u t
4 . S l i d e N u t s o n t o t h e p i p e w i t h t h r e a d s f a c i n g t h e c u t e n d s . 3 . R e m o v e C u t t i n g T e m p l a t e a n d c u t p i p e a t b o t h l o c a t i o n s .
6 . S l i d e t h e S p a c e r s b e t w e e n t h e c u t e n d a n d t h e C o m p r e s s i o n R i n g s . 5 . S l i d e t h e C o m p r e s s i o n R i n g s o v e r t h e m a r k i n g s m 7 . I n s e r t t h e C e l l V e s s e l b e t w e e n t h e c u t e n d s a n d s l i d e t h e N u t s t o e n g a g e t h e t h r e a d s o n a d e o n t h e p i p e .
t h e C e l l V e s s e l . 8 . H a n d t i g h t e n a n d c o n t i n u e t o t i g h t e n N u t s a n a d d i t i o n a l 1 / 4 t u r n w i t h t h e i n c l u d e d S t r a p W r e n c h .
9 . T h e b a c k o f t h e t i g h t e n e d N u t s s h o u l d b e l o c a t e d o n t h e I n d i c a t i n g M a r k s . I f n o t , l o o s e n N u t s i n t o t h e C e l l V e s s e l . a n d r e - p o s i t i o n t h e C e l l V e s s e l . N o t e : w h e n p r o p e r l y i n s t a l l e d , t h e c u t p i p e s d o N O T g o f u l l y
TO
POOL
on Pipe
on pipe
Mark all
Permanent
10 cutouts
Marker