Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Troubleshooting
Related Manuals for STIEBEL ELTRON HSBC 220
Summary of Contents for STIEBEL ELTRON HSBC 220
- Page 1 Operation and installation HSBC 220 Integral cylinder...
-
Page 2: Table Of Contents
15 Specification ............. 11 15.1 Dimensions and connections ......11 15.2 Installation example......... 13 15.3 Hydraulic diagram ........... 13 15.4 Wiring diagram..........14 15.5 Data table ............15 16 Logbook for installation, commissioning and main- tenance..............16 | HSBC 220 www.stiebel-eltron.co.uk... -
Page 3: Special Information
Structure of the warning notices General information 3.1.1 Section-specific warning notices u Read these instructions carefully before using the Section-specific warning notices apply to all steps in the section. appliance and retain them for future reference. www.stiebel-eltron.co.uk HSBC 220 |... -
Page 4: Intended Use
Buffer cylinder side the intended use. The steel cylinder provides hydraulic separation between the flow rates of heat pump and heating circuit. The heating water heated by the heat pump is transferred into the buffer cylinder www.stiebel-eltron.co.uk | HSBC 220... -
Page 5: Appliance Compatibility
Transport the appliance at temperatures between -20 °C Product registration and +60 °C. Register your product on the STIEBEL ELTRON website. Your u Transport the appliance in its original packaging. complete data allows us to provide quick assistance if a guaran- tee claim is made. -
Page 6: Minimum Clearances
Use the adjustable feet to compensate for any unevenness – The drain pipe can be routed via a metal funnel and a metal in the floor. downpipe. u Unscrew the adjustable feet at least 15 mm. www.stiebel-eltron.co.uk | HSBC 220... -
Page 7: Heating Water Connection
Carry out a tightness check. duced cross-sections. u To open the T&P valve, turn it anti-clockwise. u Check that water can flow unimpeded through the drain pipe to the drain. www.stiebel-eltron.co.uk HSBC 220 |... -
Page 8: Commissioning (Qualified Contractors)
Parameter the amount of heat. DIAGNOSIS / RELAY TEST SYSTEM / DRAIN HYD u Activate the following parameters in the heat pump man- ü The appliance is disconnected from the power supply with ager. omnipolar isolation. www.stiebel-eltron.co.uk | HSBC 220... -
Page 9: Appliance Handover
Regularly activate the safety valve to prevent it from becom- ing stuck, e.g. due to limescale deposits. 11.1.1 Draining the buffer cylinder u Isolate the appliance from the power supply. u Drain the buffer cylinder via the drain valve in the lowest installed pipe. www.stiebel-eltron.co.uk HSBC 220 |... -
Page 10: Flushing The System
Also isolate all T&P valve is not units indirectly con- The type plate is located at the front of the appliance. working correctly. nected to the sys- tem. Notify a qualified contractor. www.stiebel-eltron.co.uk | HSBC 220... -
Page 11: Troubleshooting (Qualified Contractors)
Water is leaking in- The high limit safety Isolate the appliance 15 Specification termittently from the cut-out, thermostat from the power sup- tundish. or T&P valve is not ply. Close the cold working correctly. 15.1 Dimensions and connections www.stiebel-eltron.co.uk HSBC 220 |... - Page 12 Specification D0000116796 HSBC 220 Cold water inlet Diameter DHW outlet Diameter inch G 1 F T&P valve Heat pump flow Diameter Heat pump return Diameter Drain Heating flow Diameter Heating return Diameter inch G 1 F www.stiebel-eltron.co.uk | HSBC 220...
-
Page 13: Installation Example
Pressure drop generated outlet from T&P valve to tun- from tundish pressure drop, ex- by each elbow or bend dish pressed as length of straight pipe (i.e. no el- bows or bends) [min. mm] [min. mm] G 1/2 www.stiebel-eltron.co.uk HSBC 220 |... -
Page 14: Wiring Diagram
Specification 15.4 Wiring diagram PROGRAMING UNIT (FES) EB08 MA10 MA14 EB02 MA15 D0000116807 www.stiebel-eltron.co.uk | HSBC 220... -
Page 15: Data Table
Max. permissible pressure (design pressure), buffer cylinder Power consumption Max. power consumption, emergency/auxiliary heater 6.00 Max. power consumption, charging pump Max. power consumption, circulation pump, heating side Energy data Standby energy consumption DHW/ 24 h at 65 °C 1.18 www.stiebel-eltron.co.uk HSBC 220 |... - Page 16 T&P valve, nominal diameter DN 15 Expansion valve nominal pressure Expansion vessel, DHW - pre-charge pressure Expansion vessel, DHW - volume Dimensions Height 1765 Width Depth Height when tilted 1851 Weights Weight, full 371.30 Weight, empty 86.30 www.stiebel-eltron.co.uk | HSBC 220...
-
Page 17: Logbook For Installation, Commissioning And Main- Tenance
DETAILS OF REGISTRATION NO: OF REGISTERED COMPANY ID CARD (IF APPLICABLE) APPLIANCE AND TIME CONTROL INFORMATION MANUFACTURER: □ STIEBEL ELTRON MODEL □ CAPACITY □ PRODUCT NO: □ TYPE SEALED UNVENTED □ TIME CONTROL PROGRAMMER □ TIME SWITCH □ www.stiebel-eltron.co.uk HSBC 220 |... -
Page 18: Commissioning Information
HAVE YOU SHOWN THE CUSTOMER HOW TO OPERATE □ THE CONTROLS? HAVE YOU HANDED OVER ALL MANUFACTURER’S DOC- □ UMENTS TO THE CUSTOMER? CONTRACTOR SIGNATURE CUSTOMER SIGNATURE (To confirm demonstration of the appliances and re- ceipt of the instruction manual) www.stiebel-eltron.co.uk | HSBC 220... - Page 19 TEL. NO. REMARKS REMARKS SIGNATURE SIGNATURE MAINTENANCE 7 MAINTENANCE 8 DATE DATE NAME OF MAIN- NAME OF MAIN- TENANCE PER- TENANCE PER- SONNEL SONNEL COMPANY NAME COMPANY NAME TEL. NO. TEL. NO. REMARKS REMARKS SIGNATURE SIGNATURE www.stiebel-eltron.co.uk HSBC 220 |...
-
Page 20: Guarantee
This document is made of recyclable paper. u Dispose of the document at the end of the appli- ance's life cycle in accordance with national reg- ulations. www.stiebel-eltron.co.uk | HSBC 220... - Page 21 HSBC 220 |...
- Page 22 | HSBC 220...
- Page 23 HSBC 220 |...
- Page 24 Co m f o r t t h r o u gh Te c h n o l o g y STIEBEL ELTRON UK Ltd Unit 12 Stadium Court | CH62 3RP Bromborough technical@stiebel-eltron.co.uk | www.stiebel-eltron.co.uk 4 0 1 7 2 1 3 6 5 0 6 2 1...
Need help?
Do you have a question about the HSBC 220 and is the answer not in the manual?
Questions and answers