APRILIA TUONO 1000 - 2006 Manual page 56

The clutch fluid reservoir (1) is located near
the clutch lever.
Before riding and every 3,750 mi (6,000
km), check the levels of the clutch fluid in
the reservoir, see below (CHECKING THE
SYSTEM).
WARNING
Never use your vehicle if the clutch
hydraulic system is leaking.
WARNING
Have your Local aprilia Dealer check the
clutch conditions every 4,650 mi (7,500
km).
For competition use:
WARNING
Have your Local aprilia Dealer check the
clutch conditions every 2,300 mi (3,750
km).
NOTE
The engine is provided with a
hydraulic control clutch, aided by the PPC
(Pneumatic Power Clutch) exclusive
p a t e n t e d s y s t e m , w h i c h a v o i d s t h e
bouncing of the rear wheel.
56 use and maintenance TUONO 1000
CHECKING THE SYSTEM
NOTE
Carry out these checks only on a
firm, flat surface such as a concrete garage
floor.
u Place the vehicle in vertical position,
keep the handlebar in the direction of
travel.
MIN = minimum level.
MAX = maximum level.
u Make sure that the fluid contained in the
reservoir exceeds the "MIN" mark stamped
on the clutch reservoir (1).
If the fluid does not reach the "MIN" mark:
u Top up
(TOPPING UP) .
USA
2
3
1
the reservoir, see below
TOPPING UP
u Place the vehicle in vertical position,
keeping the handlebar in the direction of
travel.
CAUTION
Do not operate the clutch lever and do
not rotate the handlebar with the
reservoir filler cap (2) removed. This will
cause clutch fluid to squirt out and spill.
u Loosen and remove the cap (2).
u Remove the gasket (3).