Table of Contents
Advertisement
Quick Links
AIRES SPLIT DUCTED UNIT
Indoor
Installation and Commissioning Guide
Model Numbers
Single Phase
EVA10AS*
EVA13AS
EVA15AS
EVA17AS
EVA20AS
EVA23AS
Three Phase
EVA13AS
EVA15AS
EVA17AS
EVA20AS
EVA23AS
Split Fan-Coil**
ECA13AS / EFA13AS
ECA15AS / EFA15AS
ECA17AS / EFA17AS
ECA20AS / EFA20AS
ECA23AS / EFA23AS
* Unit illustration shown is an EVA13AS unit. EVA10AS has a single fan configuration.
** Split fan coil has a separate coil and fan.
CAUTION:
The system is charged with flammable
refrigerant, safety checks are necessary to
ensure that the risk of ignition is minimised.
IMPORTANT NOTE:
This unit is designed for use with R-32 refrigerant only.
Please read the R-32 Safety Manual and this manual carefully
before installing or operating your air conditioning unit.
Information in this manual is to be used in conjunction with
the R-32 Safety Manual.
Make sure to save this manual for future reference.
Advertisement
Table of Contents
Related Manuals for ActronAir EVA20AS
Summary of Contents for ActronAir EVA20AS
- Page 1 AIRES SPLIT DUCTED UNIT Indoor Installation and Commissioning Guide Model Numbers Single Phase EVA10AS* EVA13AS EVA15AS EVA17AS EVA20AS EVA23AS Three Phase EVA13AS EVA15AS EVA17AS EVA20AS EVA23AS Split Fan-Coil** ECA13AS / EFA13AS ECA15AS / EFA15AS ECA17AS / EFA17AS ECA20AS / EFA20AS ECA23AS / EFA23AS * Unit illustration shown is an EVA13AS unit.
-
Page 2: Table Of Contents
Indoor Unit Electrical Panel Overview Unit Dimensions and Clearances ��������������������������������������������������������������������������������������������������� 6 Indoor Unit - EVA10AS Indoor Unit - EVA13AS / EVA15AS / EVA17AS / EVA20AS / EVA23AS Two-Piece Fan Coil Indoor Unit - Upright Fan Coil with Vertical Discharge Minimum Service Areas and Airflow Clearances Installation Instructions ��������������������������������������������������������������������������������������������������������������... -
Page 3: Introduction
Check your air conditioning unit and all items against the invoice upon receiving your shipment. Inspect the unit, components and accessories for any sign of damage. If there is any damage to the unit, contact ActronAir Customer Care Department immediately on: 1300 522 722 to obtain a Goods Return Number. -
Page 4: Safety Instructions
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Safety Instructions • Only licensed HVAC technicians* should install and service air conditioning equipment. Improper service or alteration by an unqualified technician could result in significant and major damage to the product or property which may render your warranty null and void. -
Page 5: Components Overview
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Components Overview Indoor Unit Components Overview EC MOTOR COIL Single Fan for EVA10AS ELECTRICAL BOX COVER CONTROL PANEL Indoor Unit Electrical Panel Overview EMC FILTER TRANSFORMER (for EVA20/23AS models) -
Page 6: Unit Dimensions And Clearances
1000 mm between the units or between the unit and the outside perimeter is available. 3. Minimum service access areas and spaces for airflow clearances are responsibilities of the installer, ActronAir will not be held liable for any extra charges incurred due to lack of access and space for airflow. -
Page 7: Indoor Unit - Eva13As / Eva15As / Eva17As / Eva20As / Eva23As
THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide EVA MODELS 25032024.TCW EVA Dim Indoor Unit - EVA13AS / EVA15AS / EVA17AS / EVA20AS / EVA23AS W-RD NOTES: GAS PIPE INDOOR COIL Drawing is subject to change without notice. - Page 8 1000 mm between the units or between the unit and the outside perimeter is available. 3. Minimum service access areas and spaces for airflow clearances are responsibilities of the installer, ActronAir will not be held liable for any extra charges incurred due to lack of access and space for airflow.
-
Page 9: Two-Piece Fan Coil
1000 mm between the units or between the unit and the outside perimeter is available. 3. Minimum service access areas and spaces for airflow clearances are responsibilities of the installer, ActronAir will not be held liable for any extra charges incurred due to lack of access and space for airflow. - Page 10 1000 mm between the units or between the unit and the outside perimeter is available. 3. Minimum service access areas and spaces for airflow clearances are responsibilities of the installer, ActronAir will not be held liable for any extra charges incurred due to lack of access and space for airflow.
-
Page 11: Indoor Unit - Upright Fan Coil With Vertical Discharge
PROJECTION mounting hole details. 2. Minimum service access areas and spaces for airflow clearances are responsibilities of the installer, ActronAir will not be held liable for any extra charges incurred due to lack of access and space for airflow. 3. For installation with release height less than or equal to 0.6m, minimum area will be computed based on release height of 0.6m 4. -
Page 12: Minimum Service Areas And Airflow Clearances
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Minimum Service Areas and Airflow Clearances Indoor Unit - EVA13AS / EVA15AS / EVA17AS / EVA20AS / EVA23AS DUCT WORK INDOOR COIL LEFT *RIGHT... - Page 13 1000 mm between the units or between the unit and the outside perimeter is available. 3. Minimum service access areas and spaces for airflow clearances are responsibilities of the installer, ActronAir will not be held liable for any extra charges incurred due to lack of access and space for airflow.
-
Page 14: Installation Instructions
Compliance and consultation with the authorities having jurisdiction with the installation of this equipment is the responsibility of the installer. ActronAir will not be held liable for any damages or costs as a result of the installer’s failure to comply. Please refer to the matching outdoor unit Installation and Commissioning Guide for further information and details. - Page 15 NOTES This indoor unit is designed to match only with an ActronAir Series outdoor unit as specified in the Technical Selection Catalogue. The unit is supplied with factory charged dry air. Be aware of the pressurised air charge when purging. Remove the caps from the connection points and purge the system only when the field pipe connections are ready to be completed.
-
Page 16: Airflow Application Guidelines
NOTE Supply and Return Air Plenums must be as per ActronAir Plenums or equal to, or lower static pressure. Installation and Commissioning Guide - Aires Split Ducted Indoor Units Doc. No. 0525-134 Ver. 4 24xxxx... -
Page 17: Return Air Grille Sizes
EVA15AS / EFA15AS 0.30m2 0.37m2 500 x 900 = 0.45m2 EVA17AS / EFA17AS 0.36m2 1060 0.42m2 600 x 900 = 0.54m2 EVA20AS / EFA20AS 1050 0.53m2 1250 0.53m2 2 x (700 x 550) = 0.77m2 EVA23AS / EFA23AS 1200 0.60m2 1450 0.60m2... -
Page 18: Unit Lifting Procedures
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Unit Lifting Procedures WARNING WH&S regulations must be observed and will take precedence during lifting process. Do not use pipes or tube coming out from the unit to lift the unit. Crane Lifting Method DANGER Make sure rigging equipment, accessories and plant are sufficiently and safely capable to lift the unit in order to prevent... -
Page 19: Fork Lift Method
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Procedure: 1. Slip nylon slings through the pallet as shown in Figure 1. 2. Use Bow or Dee shackle to connect the slings. 3. -
Page 20: Pallet Dimensions
Installation and Commissioning Guide Pallet Dimensions NOTE Pallet fork lifting hole dimensions, all dimensions in mm. EVA10AS EVA13AS / EVA15AS / EVA17AS EVA20AS / EVA23AS Installation and Commissioning Guide - Aires Split Ducted Indoor Units Doc. No. 0525-134 Ver. 3 24xxxx... -
Page 21: Safety Drain Tray
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Safety Drain Tray NOTES • Do not use pipes or tube coming out from the unit to lift the unit. • Support drain line for long pipe run. •... -
Page 22: Zone Barrel Installation Instructions
(positions that range from 9 o’clock to 3 o’clock), as shown below: It is also recommended that only ActronAir 24V zones be connected to this system using RJ45 cable connections.RJ12 connections are not compatible on these systems. Warranty may be void if third party zones cause damage to the system. -
Page 23: Electrical Installation
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Electrical Installation All electrical work must be carried out by a qualified technician. Make sure all wiring is in accordance with local wiring rules. -
Page 24: Wiring Diagram
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Wiring Diagram EVA10AS Base Variation Code: Variation: STANDARD Model No.: Description: WIRING DIAGRAM INDOOR BOARD + 8 ZONES WITH 3 WALL CONTROLLERS Drawing No: Sheet: Revision: Drawn:... - Page 25 PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide EVA/EFA13AS Base Variation Code: Variation: STANDARD Model No.: Description: WIRING DIAGRAM INDOOR BOARD + 8 ZONES WITH 3 WALL CONTROLLERS Drawing No: Sheet: Revision: Drawn: 13/05/2024...
- Page 26 PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide EVA/EFA15AS Base Variation Code: Variation: STANDARD Model No.: Description: WIRING DIAGRAM INDOOR BOARD + 8 ZONES WITH 3 WALL CONTROLLERS Drawing No: Sheet: Revision: Drawn: 13/05/2024...
- Page 27 PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide EVA/EFA17AS Base Variation Code: Variation: STANDARD Model No.: Description: WIRING DIAGRAM INDOOR BOARD + 8 ZONES WITH 3 WALL CONTROLLERS Drawing No: Sheet: Revision: Drawn: 13/05/2024...
- Page 28 PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Base EVA/EFA20AS Variation Code: Variation: STANDARD Model No.: Description: WIRING DIAGRAM INDOOR BOARD + 8 ZONES WITH 3 WALL CONTROLLERS Drawing No: Sheet: Revision: Drawn: 01/05/2024...
- Page 29 PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Base EVA/EFA23AS Variation Code: Variation: STANDARD Model No.: Description: WIRING DIAGRAM INDOOR BOARD + 8 ZONES WITH 3 WALL CONTROLLERS Drawing No: Sheet: Revision: Drawn: 13/05/2024...
-
Page 30: Electrical Connection
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Electrical Connection NOTES • To minimise noise interference, Data and Power cable clearance should be maintained as much as possible. • All drawings are for illustration purposes only. Actual unit may vary depending on the model. •... -
Page 31: Data Cable Shielding Instructions
Aires Indoor Units Installation and Commissioning Guide Data Cable Shielding Instructions 2 Core Twisted (ActronAir Part Number: AEDC2) NOTES • Maintain the twist of the core wires up to the Green Terminal Plug. • Maximum strip length of outer insulation to the Green Terminal Plug is 50mm. -
Page 32: Circuit Breaker Size Recommendation
CRS17AS / EVA17AS EFA17AS CRS13AT / EVA13AS EFA13AS CRS15AT / EVA15AS EFA15AS CRS17AT / EVA17AS EFA17AS CRS20AT / EVA20AS EFA20AS CRS23AT / EVA23AS EFA23AS Notes: Refer to latest edition of AS/ANZ 3000 or AS/ANZ 3008 Australian/New Zealand Wiring Rules to determine required cable size. -
Page 33: Wall Controller Options
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Wall Controller Options Wall Controller Options A maximum of three (3) wall controllers in the below combinations is allowed per unit. See below table. Wall Controllers Options 1st Option... -
Page 34: Wiring Configuration : Recommended
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Wiring Configuration : Recommended NOTES • Diagram shown below is a general representation only. Refer to individual unit wiring diagram for complete wiring connection details. -
Page 35: Wiring Configuration : Alternate
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Wiring Configuration : Alternate LR7-1 WALL INDOOR UNIT LR7-1 WALL CONTROLLER LR7-1 WALL CONTROLLER CONTROLLLER (OPTIONAL) (OPTIONAL) (OPTIONAL) Installation of the Outdoor Unit securely. -
Page 36: Cable Length - Zoning
* All Zone Device Power Cable : Cat5E Spec Cables with RJ45 Connectors and Cable Boots - Green Colour • ** Total Cumulative length of all the aggregate cable must not exceed 250 meters. Consult ActronAir for longer cable length requirement. -
Page 37: Lr7-1 / Lr7-2
1 to 4 (Optional 4 Zones Piggy-Back Configuration), if 1 to 3 is 75m, then 3 to 4 must be 25m to make a total of 100m. *** Recommended maximum cable length, providing total of preceding cable connections are only 5m. ^ Total Cumulative length of all the aggregate cable must not exceed 500 meters. Consult ActronAir for longer cable length requirement. -
Page 38: Wiring Connections
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Wiring Connections LR7-1 and LC7-2 Wall Control Wiring Connections INDOOR WALL CONTROL WIRING CONTROL BOARD POWER: - BROWN / ORANGE 485 A: - BLUE WALL CONTROLLER +12V A 485 B:... -
Page 39: Lm-Rs-2 Optional Sensor Wiring Connections
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide LM-RS-2 Optional Sensor Wiring Connections INDOOR CONTROL REMOTE SENSOR WIRING BOARD PAIR 1: - BLUE / BLUE-WHITE PAIR 2: - ORANGE / ORANGE-WHITE TEMP PAIR 3: - GREEN / GREEN-WHITE SENSORS... -
Page 40: Zone Commissioning
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Zone Commissioning When the unit is powered on, zone detection will automatically start. This will take 2 minutes to complete. A zone detection can also be manually triggered on the LR7-1/LC7-2 controller by pressing the ON/OFF button and Zone 1 button for 3 seconds. -
Page 41: Maintenance Frequency Checklist
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Maintenance Frequency Checklist Regular servicing of equipment by a qualified technician is recommended every 12 months for residential applications and every quarter for commercial applications. Regular servicing of your unit helps in maintaining its optimum performance and reliability. -
Page 42: Version History
PRELIMINARY DATA ONLY THIS LABEL TO BE REMOVED ON SIGN-OFF Aires Indoor Units Installation and Commissioning Guide Version History DOCUMENT VERSION BOM VERSION UPDATE HISTORY Ver 1 -010 Released Ver 2 -010 R-32 restriction clause update Ver 3 -010 Updated image and added dimension table Ver 4 -010 Added 23kW and 23kW... - Page 43 ©Copyright 2023 Actron Engineering Pty Limited ABN 34 002767240. ®Registered Trade Marks of Actron Engineering Pty Limited. ActronAir is constantly seeking ways to improve the design of its products. Therefore, specifications are subject to change without notice. Installation and Commissioning Guide - Aires Split Ducted Indoor Units...
Need help?
Do you have a question about the EVA20AS and is the answer not in the manual?
Questions and answers