Table of Contents
Advertisement
will be damaged and will then have to be re-
placed.
Battery charging
Starting the engine requires a well charged bat-
tery.
Fig. 203 Engine compa rtment: connectors for a charger
and jump start cables
Always read and heed all WARNINGS
below
~ &. and
¢
A
in Working on the battery on
page 232.
• Switch off the ignition and all electrical con-
sumers .
• Make sure the area is well ventilated when you
charge the battery.
• Open the engine hood
~
page 220.
• Remove the cover
(D
by pressing on the arrow
¢ fig. 203.
• Open the cover @ on the positive terminal.
• Connect the charger connectors according to
the instructions to the jump start bolts. (Bolts
under the red cover= "positive" , Bolts with hex
head
=
"negat ive").
• Only now plug the mains lead for the charging
equipment into the wall outlet and turn it on
¢ &,,.
• Make sure the charging rate is not over
30 amps/14.8 Volt.
• When the battery is fully charged: Turn the
charging equipment off and remove the mains
lead from the wall outlet .
• Now remove the clamps for the charging equip-
ment.
~
• Close the red cover on the positive pole.
0
~
• Close the hood ~
page 221.
rl
I.Cl
U"I
rl
I.Cl
rl
Checking
and Filling
A discharged battery can freeze at temperatures
of only 32 F
0
(0 °C). Allow a frozen battery to
thaw completely before attempting to charge it
¢
& .
However , we recommend not using a
thawed battery again because the battery casing
can be cracked due to ice formation and can leak
battery acid.
Battery charging (Maximum charging rate of
30 amps/14.8 Volt)
When charging at
low
voltages (e.g . with a trick-
le charger), the battery cables do not have to be
disconnected first. The battery caps should
not
be opened when charging a battery.
It is not necessary to remove the battery from
the luggage compartment,
and it is also not nec-
essary to disconnect the cables .
Fast charging the battery (charging rate
above 14 .8 Volts)
For technical reasons do not use a battery charg-
er that uses voltage greater than 14.8 Volts to
charge your vehicle's battery.
.&_
WARNING
Charg ing a battery can be dangerous.
- Always follow the operating instructions
provided by the battery charger manufactur-
e r when charging your battery.
- Never charge a frozen battery. It may ex-
p lode because of gas trapped in the ice. Al-
low a frozen battery to thaw out first .
- Do not reuse batteries which were frozen.
The battery housing may have cracked and
weakened when the battery froze.
- Charge the battery in a well ventilated area.
Keep away from open flame or electrical
spark. Do not smoke. Hydrogen gas generat-
ed by the battery is explos ive.
- To reduce the danger of explosion, never
connect or disconnect charger cables while
the charger is operating.
- Fast charging a battery is dangerous and
should only be attempted by a competent
technician with the proper equipment.
- Battery acid that may spill during charging
should be washed off with a so lution of
233
Advertisement
Table of Contents
