Removing The Fuel Tank - KTM 250 SX-F EU 2011 Owner's Manual

SERVICE WORK ON THE CHASSIS

Removing the fuel tank

x
10.32
Danger
Fire hazard Fuel is highly flammable.
–
Never refuel the vehicle near open flames or burning cigarettes, and always switch off the engine first. Be careful that no
fuel is spilt, especially on hot vehicle components. Clean up spilt fuel immediately.
–
Fuel in the fuel tank expands when warm and can escape if the tank is overfilled. See the notes on refueling.
Warning
Danger of poisoning Fuel is poisonous and a health hazard.
–
Avoid contact between fuel and skin, eyes and clothing. Do not inhale fuel vapors. If fuel gets into your eyes, rinse immedi-
ately with water and contact a doctor. Wash affected skin areas immediately with soap and water. If fuel is swallowed, con-
tact a doctor immediately. Change clothing that has come into contact with fuel. Store fuel in a suitable canister according
to regulations and keep it out of the reach of children.
–
Remove the seat. (
–
Disconnect electric plug-in connection
–
Thoroughly clean plug-in connection
Info
Under no circumstances should dirt enter into the fuel line. Dirt in the fuel
line will clog the fuel injection jets.
100922-10
–
Disconnect the plug-in connection of the fuel line.
–
Mount wash cap set
Wash cap set (81212016000)
–
Remove the tube from the fuel tank breather.
100949-10
–
Remove screws
B00315-10
–
Remove screw
B00316-10
p. 40)
of the fuel pump.

of the fuel line using compressed air.

.

with the collar bushing.

with the rubber bushing.

44