Kohler 10CCOZ61 Service Manual page 50

Problem
ELECTRICAL
SYSTEM
Battery will Loose or corroded
not charge or
goes dead
Sulfated or worn-out
Defective alternator
Loose or defective
Defective alternator
Loose or corroded
engine ground strap
Problem
Starter does
not work
properly
Battery cables undersize
engine ground strap
TP-5648 8/93
Possible Cause
connections
battery
alternator belt
voltage regulator
Possible Cause
Loose or corroded
connections
Low battery output
Defective starter
solenoid
Defective start/stop
switch
Defective wiring
Defective starter
Loose or corroded
Corrective Action
Clean and tighten
connections
Check electrolyte level
and specific gravity
(batteries with filler
caps only)
Test and replace,
if necessary
Adjust belt tension
or replace belt
Test and replace,
if necessary
Clean and tighten
Corrective Action
Clean and tighten loose
connections
Check electrolyte level
and specific gravity
(batteries with filler
caps only)
Check starter solenoid
Replace starter
solenoid, as necessary
Replace switch
Check wiring
Replace starter
Select proper size
cable
Clean and tighten
Reference
Section 3. Battery
Section 3. Battery
Section 7. Component
Testing
Section 3. Belt Tension
Section 7. Component
Testing
Section 3. Battery
Reference
Section 3. Battery
Section 3. Battery
Section 7. Component
Testing
Engine Service Manual
Section 7. Component
Testing
Section 8. Wiring Diagrams
Engine Service Manual
Section 1. Specifications
Chart--Installation
Operation and Installation
Manual--Electrical System
Section 3. Battery
General Troubleshooting 4-11